ArticlePDF Available

Quantification of Ergonomic Exposures for Restaurant Servers

Authors:

Abstract

Musculoskeletal disorders have the potential to impact a tremendous number of waitresses and waiters in the United States, yet very little is known about the ergonomic risk factors that these workers routinely encounter. The objective of the study was to document the potential ergonomic stressors that restaurant servers are exposed to during a typical shift. During a typical work shift, the following data was collected on twenty servers from three different restaurants: the weight and frequency of trays transferred as well as postures adopted when serving by direct observation; amount of time sitting, standing and walking by an ActivPal activity device; and workload perception and current discomforts by survey. Observations revealed that servers carried 16.4 kg per hour or 6.3 kg per tray. More than 90% of the servers reported spending between 5 and 8 hours standing during their shift. Objective measures confirmed spending a large amount of time on their feet (76% of time standing or walking). At the end of the shift, the body region with the greatest end of the shift discomfort was the upper back (55%), followed by the neck (45%) and lower back (50%) regions. In all, the current study provides a glimpse into the demands on the servers. All indications were the current results were lower than normal shifts. The bottom line was that the weight of the tray transferred, time spent standing and walking, and the awkward postures adopted by servers increase the risk of musculoskeletal disorders (MSDs). However, no direct link to MSDs can be drawn from the current study. In general, while the weight or number of trays served per hour was not particularly high, the load lifted represented a risk to the servers, especially when peak times require many more trays served.
Quantification of Ergonomic Exposures for Restaurant Servers
Kermit G Davis1*
Angela C Wills ,
1 and Susan E Kotowski2
1Low Back Biomechanics and Workplace Stress Laboratory, University of Cincinnati, Cincinnati, Ohio, United States
2College of Allied Health Sciences, University of Cincinnati, Cincinnati, Ohio, United States
*Corresponding author: Kermit G Davis, Low Back Biomechanics and W orkplace Stress Laboratory , University of Cincinnati, Cincinnati, Ohio, United States, T el:
+513-558-2809; E-mail: Kermit.davis@uc.edu
Received date: March 1, 2016; Accepted date: May 25, 2016; Published date: May 31, 2016
Copyright: ©
use distribution, and reproduction in any medium, provided the original author and source are credited.
Abstract
Musculoskeletal disorders have the potential to impact a tremendous number of waitresses and waiters in the
United States, yet very little is known about the ergonomic risk factors that these workers routinely encounter. The
objective of the study was to document the potential ergonomic stressors that restaurant servers are exposed to
during a typical shift. During a typical work shift, the following data was collected on twenty servers from three
different restaurants: the weight and frequency of trays transferred as well as postures adopted when serving by
direct observation; amount of time sitting, standing and walking by an ActivPal activity device; and workload
perception and current discomforts by survey. Observations revealed that servers carried 16.4 kg per hour or 6.3 kg
per tray. More than 90% of the servers reported spending between 5 and 8 hours standing during their shift.
Objective measures confirmed spending a large amount of time on their feet (76% of time standing or walking). At
the end of the shift, the body region with the greatest end of the shift discomfort was the upper back (55%), followed
by the neck (45%) and lower back (50%) regions. In all, the current study provides a glimpse into the demands on
the servers. All indications were the current results were lower than normal shifts. The bottom line was that the
weight of the tray transferred, time spent standing and walking, and the awkward postures adopted by servers
increase the risk of musculoskeletal disorders (MSDs). However, no direct link to MSDs can be drawn from the
current study. In general, while the weight or number of trays served per hour was not particularly high, the load
lifted represented a risk to the servers, especially when peak times require many more trays served.
Keywords: Waitress; Liing; Standing; Musculoskeletal disorders
Introduction
In 2011, the total number of waitresses and waiters employed in the
United States was 2.2 million [1]. Further, the number of servers is
expected to grow by about 10% between 2006 and 2016 [1]. Full-
service restaurants (e.g. sit down facilities) represent approximately
40% of all restaurants in the industry. As such, these full-service
establishments employ about 900,000 servers [1].e typical worker
has traditionally been young, low education and oentimes in
transitional employment.
While musculoskeletal disorders (MSDs) appear to be substantial
for wait sta with incidence rate of 9.8 per 10,000 servers [2], little is
known about the actual ergonomic stressors that servers are exposed to
during their typical work shi. rough casual observation, one can
see many factors present for servers that have traditionally been
associated with MSDs such as amount of weight lied and carried,
awkward postures including forward or side bending, extended
reaching, repetitive liing of heavy and awkward loads, and prolonged
standing.
e amount of weight that servers carry constantly changes with
every order, but appears to be signicant. A server can have just a soup
and salad for one order, but the next order may be multiple entrée
plates on a tray. Food can be carried by hand or by tray. While there
has been no studies actually quantifying the weight that servers li and
carry, weight has been identied as a risk factor for low back injuries in
other industries [3]. e critical value identied seems to be 11.4 kg for
low back injuries [3-5]. In a study by Marras and associates [6], the
average weight handled by high risk jobs was 11.4 kg as compared to
8.3 kg for low risk jobs. Further, Neumann et al. [7] reported increased
risk for 12 kg weights. Bottom line, the amount of weight lied is
potential a risk factor for low back injuries and potentially shoulder
injuries and needs to quantied.
Another potential important ergonomic risk factor for servers is
task repetition. e servers are constantly serving plates and trays of
food. However, the exact number of times a server lis and carries of
food, drinks, and trays is unknown. Based on previous research,
repetitive liing has been found to be associated with low back and
shoulder injuries when liing weight above 11.4 kg [5,8]. Ferguson and
Marras [9] reported 62% of the studies that investigated li rate
reported a positive association with low back disorders.
Wait sta routinely face situations that require them to work around
dierent obstacles such as reaching around individuals while serving,
reaching across tables to place or pick up plates or glasses, or having to
hold plates or glasses away from the body because multiple plates are
staged on the server’s arm. ese situations impact the moment arm
between the low back to the object in the hand. Several previous
studies focusing on material handing have found an increased risk of
low back pain (LBP) as the horizontal distance increases Marras et al
[6,10,11].
Servers are required to perform many dierent activities that may
produce awkward postures: preparing for a meal to be brought out
from the kitchen; reaching into the windows in the kitchen to get the
plates of food; reaching for a tray jack; picking up and carrying the
food; holding trays above the shoulders and head; placing the trays
down on the jack or table; bending down to pick up the dishes of tray
Journal of Ergonomics Wills AC, J Ergonomics 2016, Open Access 6: 3
http://dx.doi.org/10.4172/2165-7556.1000166
Research Article JER, an open access journal
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
2016 Wills AC et al. This is an open-access article distributed under the terms of the Creative Commons Attribution License, which permits unrestricted
or table; and reaching across table or around people to serve their food.
Flexion or extension of various body regions (e.g. trunk, shoulders,
etc.) individually, or in combination with twisting are factors known to
increase LBP [3,8,9,12-15]. However, actual postures during serving
have yet to be quantied.
Serving jobs require long periods of being on your feet without
frequent breaks. Two reasons for infrequent breaks are: 1) servers are
not given the opportunity by management and 2) servers do not want
to miss out on the potential opportunity to make money while on a
break. Along with standing, severs are constantly walking around the
restaurant assisting customers or performing serving duties. Walking
and standing for long durations have been related to low back pain and
lower extremity disorders. Researchers have identied prolonged
standing and walking with many dierent negative health outcomes
such as chronic venous insuciency [16-19], varicose veins [20]
symptom free venous reux [21], hip osteoarthritis [22], and leg and
foot pain [23]. A strong relationship has been found for prolonged
occupational standing and low back pain [23-26]. As with the other
potential risk factors, prolonged standing and long periods of being of
their feet (e.g. walking) appear to plague servers on their jobs but there
has been no actual measurement.
While there is ample support of the risk factors commonly seen for
servers, less than a handful of studies exist which focus specically on
restaurant service sta. Dempsey and Filiaggi [27] studied the job
demands among 100 servers in 10 casual dining areas using a cross-
sectional survey provided to the servers. e survey documented the
servers’ musculoskeletal discomfort attributed to work. e top two
body regions suering pain were low back (28%) and shoulder (11%)
[27]. Jones and associates [28] examined the physical demands of
occupational tasks in neighborhood pubs in British Columbia, Canada.
ese investigators looked at three specic tasks in relation to servers
using RULA (Rapid Upper Limb Assessment): carrying task, tray
liing task and stoop-to-serve task, with all three tasks being deemed
to be a signicant risk to the servers based on RULA. Another group
looked into training techniques that focused on safe tray carrying
among cocktail servers [29]. However, it appeared that training was
not a viable intervention for servers.
From the summary of the limited studies that have investigated the
potential risk factors that servers may be exposed to while serving
customers as well as casual observation, there is a need for direct
quantication of the ergonomic risk factors for servers. e objective
of this research study was to determine the exposure to ergonomic risk
factors for servers (waitresses and waiters) in restaurant settings.
Additionally, the study will document the discomfort that resulted
from a single shi.
Materials and Methods
Study Overview
A research team observed and measured the ergonomic stressors for
servers at three dierent restaurant locations in a Midwest
metropolitan area. An entire shi was observed for each server as they
performed their normal job duties. Ergonomic stressors were directly
assessed by either observation (e.g. postural demands, frequency of
events, etc) or quantitative measures such as weight of the trays being
transferred to and from the tables. Two surveys were completed by the
servers to document current perceived demands and discomfort
symptoms in specic body regions.
Study Sites
All three of the restaurant locations specialized in their own style of
cuisine. ey were all full-service restaurants and open 7 days a week.
Restaurants 1 and 2 were privately owned while restaurant 3 was a
franchise.
Restaurant 1 specialized in American-style bar food (burgers, wings,
pretzels, salads, etc.). Restaurant 1 had a large semi-circular bar in the
middle of the restaurant, a large kitchen area, and three dining
locations. e restaurant had a total of 13 servers and 3 bartenders,
where one server also worked as a bartender on certain nights. During
a typical night shi 4 to 6 servers would be working, while aernoon
shis usually had 2 to 3 servers.
Restaurant 2 specialized in hamburgers (burgers and salads).
Restaurant 2 had a small square bar in the middle of the restaurant, a
large kitchen behind the bar, and a dining area that completely
surrounded the bar area. is location had a total of 12 servers and 3
bartenders. e typical lunch shi would have 3 to 4 servers while
dinner shis had 5 to 6 servers.
Restaurant 3 specialized in Italian cuisine (pastas, pizza, calzones,
salads, etc). Restaurant 3 had a large kitchen with a relatively small
dining area and no bar. It also had a small area to serve take-out
orders. is location employed 7 servers and no bartenders. A typical
dinner shi had 5 severs while the typical lunch shi had 3 servers.
Subjects
A total of 20 wait sta (5 males and 15 females) were recruited from
one of the three restaurant settings in a large Midwest metropolitan
area. Inclusion criteria for participation were the following: at least 2 or
more years of experience serving (total), serving at current location for
more than 6 months, no major surgeries within the last 2 years, not
currently pregnant, and being older than the age of 18 (which was for
convenience for consent but was not an issue given all three restaurants
served alcohol and required servers to be at least 18 years old).
Experimental Design
e design of the study was a cross-sectional observational study
where one member of the research team quantied the stressors of
each of the waitresses/waiters over their entire shi. At each of the
restaurants, there were multiple shis observed including day (lunch)
and night (dinner) and a mix of both shis. A typical day shi at all
three locations started between 10:30-11:00 am and went till
2:00-3:00pm. e dinner shi started between 4-5pm and would last
till 9-10 pm. e hour between 3-4 pm was designated for shi change,
clean up and restocking of the plates, drinking cups and food. e
breakdown of the observed shis for this study includes 9 day shis
and 11 night shis.
Assessment Techniques
Observation worksheet
Frequency of tray carrying and postures of specic body joints were
recorded by one of the researchers through data worksheets. e
worksheet had checklist entries that recorded the number of times a
tray was transferred, what was being carried, and poor postures for the
neck, shoulders, hands and wrists, elbows, upper back, lower back,
hips, knees and lower legs and feet. e types of poor postures were
Citation: Wills AC, Devis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 2 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
based on RULA categories [30]. e following adverse posture
categories were used: Neck (exion > 20o, lateral extension > 30o,
extension > 30o, rotation > 70o); Trunk (exion > 60o, rotation < 30o ,
lateral exion > 15o, extension > 25o); Shoulder (forward exion >
180o, abduction > 180o, external rotation > 90o); Elbow (exion <
145o), Upper arms (exion > 20o, extension > 90o); Lower arms
(exion < 60o or > 100o); Wrist (exion and extension > 45o , radial/
ulnar deviation > 30o). For each li, carry, or transfer of the trays, a
research team member marked down the body posture relating to each
specic body region.
Additional information including observation of how each server
carried trays of food or held the food with their hands was recorded.
ere were six categories of how the tray was carried: 1) in front of the
server, 2) on the shoulder, 3) on the nger tips, 4) with a at palm, 5)
above the shoulder in the air, and 6) number of hands (e.g. using one
hand versus two hands). For any served tray, there could have been a
combination of any of the 6 categories at one time. For example, a
server could carry the tray of food on their shoulder with a at palm or
on their ngertips with one hand with or without support of the
second hand. Lastly, the type of tray jack used when setting down trays
was recorded. ere are four tray jack categories: 1) waist high tray
jack, 2) mid-thigh high tray jack, 3) holding the tray while serving, and
4) placing the tray on a table surface.
Data were gathered about the number of plates/glasses on the tray.
e categories of number of glasses were: 1) bar glasses which were full
of liquid, 2) plastic cups lled with liquid and 3) empty glasses, ether
plastic or glass. e categories for the number of plates handled were:
1) full plates of food, 2) empty plates of food and 3) plates that still had
some food remaining on them. For each of the glass and plate
categories, a total number was recorded for each tray handled.
Tray weight
e tray weight was measured by having the server step on a scale
located in a convenient position near the kitchen. e weight of the
server and tray was recorded and then converted into tray weight later
by subtracting the weight of the server. is method allowed for quick
measurement without compromising the food safety and quality.
Physical activity
e amount of time sitting, standing and walking was captured by a
physical activity logging device known as ActivPALTM (PAL
Technologies Limited, United Kingdom). e ActivPalTM device was
placed on upper thigh of the server prior to the beginning of each
observed shi. e ActivPALTM is lightweight (15 grams) and small (7
mm thick) rectangular device capable of acquiring activity for 7 days
and downloaded to a personal computer for further processing. e
ActivPALTM was used to document the amount of time spent sitting,
walking and standing as well as number of steps taken and energy
expenditure. e amount of time spent in the dierent categories was
converted into percentage of time per hour while the number of steps
taken was calculated per hour of each shi. e validity of
ActivPALTM has been shown to be strong by Aminian and Hinkson
[31], with correlations between ActivPalTM and actual observation to
be above 99% (r=0.99 ± 0.01). ese researchers also reported that
there was no misclassication of leg dgeting to actual walking steps.
Current symptom survey
Participants completed a Current Symptom Survey at the start and
end of the observed shis. e Current Symptom Survey assessed
current discomfort in various body regions on a numeric analogue
scale of 0 to 10; 0 being no pain experienced, 3 mild pain, 5 moderate
pain, and 10 severe pain. e 9 body regions were neck, shoulders,
elbows, hands/wrists, upper back, low back, hip, knees and lower legs,
and feet. e numerical analogue discomfort scale has been widely
utilized by many elds to document pain reliably and accurately for
pain attributable to cancer, musculoskeletal, rheumatic, and surgical
[32].
Workload perception survey
e Workload Perception Survey assessed whether the server felt
the observed shi was typical of the work demands for their restaurant
for the given day and shi. e survey was composed of 7 questions
that ask about 1) how the typical shi was relative to the current one
being observed, 2) how many people they serve per hour on a normal
day, 3) how many tables they would normally serve, 4) how many
hours a week do they work, 5) how long they believe they stand, 6)
how oen they get to take breaks, and 7) what days do they normally
work in a week.
Experimental procedures
Upon arriving at each of the restaurant locations, the logistics of the
study were explained verbally to all of the participants (on a one-on-
one basis) by the Primary Investigator (PI). Once any questions or
concerns were addressed, the consent process was completed
(approved by the Institutional Review Board) that included reading
and signing the consent form. Next, each participant completed a
Current Symptom Survey and the ActivPALTM was attached to upper
thigh (via of the participants which included two sided tape and a self-
adhesive bandage wrap). e ActivPal device was worn for the entire
duration of the shi. Next, body weight was measured on a digital scale
and recorded (fully clothed and wearing shoes). At this point, the
servers started their shi with the research team member observing
their postures and measuring the loads of the trays being carried..
Shis were observed based on each server’s normal working shis and
day which included all days of the week, peak and slow periods, and
multiple restaurants. When the server had a tray of food that needed to
be served, the individual stepped on the scale while holding the tray of
food so the weight of the tray and body were recorded. e weight of
the tray and food was determined by taking total weight and
subtracting the body weight.
At the end of the observed shi, the ActivPalTM was removed from
the subject with the ActivPalTM being placed in a horizontal position
to signal the stop in recording of the physical activity. e data was
later transferred onto a computer for subsequent analyses. Next, the
subjects completed the second of the two Current Symptom Surveys
and the Workload Perception Survey. Aer the nal two surveys were
collected, the subjects were paid a small token of appreciation ($20.00)
for their participation.
Statistical Analysis
Descriptive statistical analysis (means, standard deviations,
frequencies, etc.) was used to determine estimates of the exposures for
servers. In general, summary tables provided means or frequencies of
events for the dierent ergonomic stressors. Given the nature of the
Citation: Wills AC,Devis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 3 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
study was observational and exploratory with limited subjects, no
statistical analyses were deemed appropriate. As a result, summary
data of the observations were provided in table format.
Results
Overall Hours Collected and Demographics
e total amount of time the servers were observed was 68.9 hours.
e demographic data are summarized in Table 1. Restaurant 1 was
observed for 30.35 hours, restaurant 2 for 15.4 hours, and restaurant 3
for 23.15 hours. Of the 20 servers observed, there were 5 males (25%)
and 15 females (75%) with 2 males and 6 females for restaurant 1, 2
males and 3 females for restaurant 2, and 1 male and 6 females for
restaurant 3. e average age for all 20 servers was 26 years. For servers
working at restaurant 1, the average age was 26.4 years, restaurant 2
was 23.8 year, and restaurant 3 was 27 years. e height and weight of
the servers at the three restaurants were similar to that of a typical
working population (Table 1).
Restaurant Age
(Years)
Standing
Height (cm)
Body Weight
(kg)
Total Experience
(Years)
Current
Experience
(Months)
Observation Time
(Hours/Server)
Total Time
Observed
(Hours)
1 26.4 (6.8) 168.0 (6.3) 72.8 (25.8) 5.0
(3.0)
14.6
(8.1)
3.8
(0.8)
30.4
2 23.8 (2.9) 170.2 (8.6) 68.7 (20.1) 3.0
(1.6)
15.0
(12.0)
3.1
(0.4)
15.4
3 27.0 (3.5) 169.5 (7.1) 76.3 (20.3) 4.7
(2.2)
22.3
(18.6)
3.3
(0.9)
23.2
ALL 26.0 (4.9) 169.0 (6.9) 73.0 (21.7) 4.4
(2.5)
17.4
(13.3)
3.4
(0.8)
68.9
Restaurant Gender TOTAL Shift Type
Male Female Lunch Dinner
1 2 6 8 2 6
2 2 3 5 3 2
3 1 6 7 4 3
ALL 5 15 20 9 11
Table 1: Demographic data, observation time and restaurant breakdown for the three restaurants (average and standard deviation).
Overall, the average length of experience was 4.4 years of total years
in serving (Table 1). Restaurant 1 had slightly more years of experience
(5 years) with restaurant 2 having less (3 years). Restaurant 3 had
about the overall average with 4.7 years of experience in serving. e
breakdown of shis (Table 1) was the following: Lunch shi had 9
servers (45%) with restaurant 1 having 2 servers, restaurant 2 having 3
servers, and restaurant 3 having 4 servers and Dinner shi had 11
servers (55%) with restaurant 1 having 6 servers, restaurant 2 having 2
servers, and restaurant 3 having 3 servers.
Workload perception
e results from the Workload Perception Survey indicated that
only 40% of the servers felt the observed shi was a typical shi while
the remaining 60% thought it was lighter than usual (40% lighter and
20% lightly lighter) (Table 2). e number of people typically served
during a normal shi reported by the servers had 5% reporting 1 to 3
people, 25% reporting 7 to 9 people, 30% reporting 10-12 people, and
40% reporting 12 or more people. e number of tables served per
hour was reported by 5% as 1 to 2 tables, 40% as 3 to 4 tables, 35% as 5
to 6 tables, and 20% as 9 or more tables per hour. e number of hours
worked in a week was reported to be less than 20 hours a week by 10%
of the servers with 50% of the servers being part time, 35% of servers
being full time (40 hours per week) and 5% of the servers working
more than 40 hours a week. A small percentage of servers (5%)
reported standing more than 2 hours but less than 5 hours while 90%
of severs reported standing more than 5 hours but less than 8 hours.
About 5% of the servers actually felt they stood more than 8 hours.
When asked about the perceptions of breaks, 10% indicated that they
took a break once an hour, 40% indicated once a shi, 35% said
whenever they wanted, and 15% never took a break.
Finally, when asked what days they normally work, 60% of the
servers indicated that they mixed days, 5% said only weekends, 15%
said only weekdays, 5% only mornings, and 15% only nights.
Would you describe today's shift as FREQ %
Significantly lighter than normal 8 40
Citation: Wills AC, Devis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 4 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
Slightly lighter than normal 4 20
Typical of normal 8 40
Slightly heavier than normal 0 0
Significantly heavier than normal 0 0
How many people do you serve per hour on a normal day? FREQ %
1 to 3 people 1 5
4 to 6 people 0 0
7 to 9 people 5 25
10 to 12 people 6 30
12 or more people 8 40
On your typical shift, how many tables would you serve per hour? FREQ %
1 to 2 tables per hour 1 5
3 to 4 tables per hour 8 40
5 to 6 tables per hour 7 35
7 to 8 tables per hour 0 0
9 or more tables per hour 4 20
On average how many hours a week do you work? FREQ %
Less than part time (less than 20 hours a week) 2 10
Part time (20 hours a week) 10 50
Full time (40 hours a week) 7 35
More than 40 hours a week 1 5
On average how long do you stand while working your normal shift? FREQ %
Less than an hour 0 0
Greater than an hour but less than 2 hours 0 0
Greater than 2 hours but less than 5 hours 1 5
Greater than 5 hours but less than 8 hours 18 90
Greater than 8 hours 1 5
How often do you get to take a break? FREQ %
Once an hour 2 10
Once a shift 8 40
Whenever you want 7 35
Never 3 15
What days do you normally work within a week? FREQ %
Mixed 12 60
Only Weekends 1 5
Only Weekdays 3 15
Citation: Wills AC, Devis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 5 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
Only Mornings 1 5
Only Nights 3 15
Table 2: Server perception of their typical workload based on Workload Perception Survey.
Current symptoms before and aer shi
ere was a general trend of increased pain at the end of the shi.
e largest increase in pain for any of the body regions occurred in the
upper back of 0.80 (55%). e other regions with increased pain at the
end of the shi were neck (increased by 0.65 or 45%), lower back
(increased by 0.60 or 50%), hand/wrist (increased by 0.45 or 35%), and
leg/foot (increased by 0.40 or 60%). e body regions that had little
increase in pain at the end of the shi were the hips with an increase of
0.20 (15%) and the elbows with an increase of 0.10 (15%). Two of the
body regions actually had a decrease in pain between the end and start
of the shi: shoulders had an average decrease of 0.10 (45%) and knees
had a decrease of 0.05 (30%). Figures 1 shows how many of the body
regions had a greater number of individuals with discomfort at the end
of the shi than the start, specically neck, shoulder, elbow, hand/
wrist, upper back, and leg/foot.
0
10
20
30
40
50
60
70
80
90
100
NECK SHOULDER ELBOWS HAND/WRIST UPPER BACK LOWER BACK HIP KNEE LEG/FOOT
Percentage of Servers with Discomfort (%)
Body Region
Before After
Figure 1: Percentage of servers in the study that had discomfort at the start and end of the shi being observed.
Weight lied and transferred
e average amount of weight per hour lied for all servers was 16.4
kg (see Table 3 for summary of the weights). While the average weight
and total number of trays carried varied across the restaurants, the
total weight per hour was 16.4 kg, average amount of weight per tray
was 6.3 kg and number of tray carried per hour was 2.7. e total
amount of weight per hour for lunch service was 16.3 kg in relation to
the amount of weight per hour during the dinner service which was
16.6 kg. e amount of weight per tray for lunch service versus dinner
service was 7.1kg and 5.8 kg, respectfully. Finally, the number of trays
that were carried between the two shis was 2.5 kg for the lunch shi
and 2.9 kg for the dinner shi.
e averaged total amount of weight over shi for tray holding
postures was 15.6 kg when using combination of transfers, 13.2 kg
when transferring using ngers to support the tray, 16.8 kg when the
tray is held in front of body, and 15.2 kg when transferring the tray on
the shoulder. e amount of weight averaged per tray was: 5.5 kg for
the combination transfer, 5.7 kg when using ngers technique to
transfer the tray, 6.7 kg when the server held tray in front of body, and
6.8 kg when server carried the tray on the shoulder.
Restaurant Total Weight Per
Hour (kg)
Weight Per
Tray
(kg)
Number of Trays
Carried Per Hour
(#)
1 13.1
(10.8)
5.7
(2.1)
2.3
(1.5)
2 15.3
(8.3)
7.3
(2.6)
2.2
(0.8)
3 21.2 6.3 3.6
Citation: Wills AC, Devis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 6 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
(12.6) (2.4) (2.0)
All 16.4
(11.3)
6.3
(2.4)
2.7
(1.7)
Carrying Style
Combo 15.6
(9.1)
5.5
(2.3)
2.7
(0.6)
Finger 13.2
(13.6)
5.7
(7.4)
1.7
(0.8)
Front 16.8
(12.0)
6.7
(6.5)
3.1
(0.8)
Shoulder 15.2
(3.1)
6.8
(6.0)
1.3
(0.2)
Shift Type
Lunch 16.3
(12.3)
7.1
(2.5)
2.5
(1.6)
Dinner 16.6
(10.7)
5.8
(2.2)
2.9
(1.7)
Table 3: Amount of weight carried (per hour and per tray) and number
of trays as a function of restaurant, carrying style and shi type
(average and standard deviation).
Transfer technique and usage of tray jacks.
e frequency of the usage of the dierent tray transfer techniques
is summarized in Table 4. For all 3 restaurants, there were a total of 133
tray transfers. ere were 93 trays (69.9%) that were carried in front of
the servers. On the other hand, the shoulder and hand at techniques
were used less frequent, 23 (17.3%) and 10 (7.5%), respectively. Finally,
few transfers were observed to use the ngertip method (around 5% of
observed transfers). During the lunch shi at all of the restaurants
combined, 18% (24 times) of the servers carried the tray in front of
themselves, 10.5% (14 times) on their shoulders, and 4.5% (6 times) on
their ngertips and there were no servers who carried the tray with a
at palm. During the dinner service, 51.9% (69 times) of the servers
carried the tray of food in front of their bodies, 6.8% (9 times) on their
shoulders, 7.5% (10 times) carried the tray with a at palm, and 0.8%
(1 time) used their ngertips. Lunch and dinner servers seemed to
prefer carrying the trays in front of their body as opposed to any other
form of tray transfer. ere were 4 dierent ways the trays could have
been placed when serving the food. For all servers, there were a total of
124 tray jacks used.
Tray Jack
at Waist
Level
Tray Jack at
Thigh Level
Holding
Tray
Set on
Table
Tota
l
All 14 (10.5%) 9 (6.8%) 26 (19.5%) 84 (63.2%) 133
Shift Type
Lunch 9 (6.8%) 9 (6.8%) 6 (4.5%) 22 (16.5%) 46
Dinner 5 (3.8%) 0 (0.0%) 20 (15.0%) 62 (46.6%) 87
Restaurant
1 0 (0.0%) 9 (6.8%) 12 (9.0%) 12 (9.0%) 52
2 14 (10.5%) 0 (0.0%) 5 (3.8%) 5 (3.8%) 24
3 0 (0.0%) 0 (0.0%) 9 (6.8%) 48 (36.1%) 57
Carrying Style
In Front On Shoulder Flat Palm Finger Tips Total
All 93 (69.9%) 23 (17.3%) 10 (7.5%) 7 (5.3%) 133
Shift Type
Lunch 24 (18.0%) 14 (10.5%) 0 (0.0%) 6 (4.5%) 44
Dinner 69 (51.9%) 9 (6.8%) 10 (7.5%) 1 (0.8%) 89
Restaurant
1 28 (21.1%) 11 (8.3%) 10 (7.5%) 3 (2.3%) 54
2 12 (9.0%) 8 (6.0%) 0 (0.0%) 4 (3.0%) 24
3 53 (39.8%) 4 (3.0%) 0 (0.0%) 0 (0.0%) 57
Table 4: Frequency of the number (percentage of total) of times a tray
was placed at table and style of carrying tray.
Transfer of Trays
Overall, the prevalence of carrying tray methods was 93 in front of
server (23.25 trays/hour), 23 on the shoulders (65 adverse postures/
hour), 10 at palm (7.5 trays/hour), and 7 on their ngertips (5.3 trays/
hour). During the lunch shi, there were a total of 24 (18.0%) times
where the servers carried the tray in front of them, 14 (10.5%) carried
the trays on their shoulders, 6 (4.5%) carried the trays of their
ngertips, and no one carried them with a at palm. During dinner
shis, it was observed that a total of 69 (51.9%) times where the server
carried the trays in front of them, 9 (6.8%) times where the server
carried the trays on their shoulders, 10 (7.5%) times where they carried
trays with a at palm and 1 (0.8%) time where a server used ngertips
to carry the tray.
Postures
Table 5 provides a summary of the awkward postures for the
dierent body regions. A total of 260 poor postures were recorded
during the observations. Several body regions were observed to have
the greatest number of poor posture including elbow exion, shoulder
abduction, wrist extension, and neck side bending. For all three of the
restaurants, there were a total of 85 observed instances of elbow
exion, the leading body region for poor postures: restaurants 1, 2 and
3 had 32, 20, and 33 awkward elbow postures, respectively. Neck side
bending was the 2nd most occurring posture for all three restaurants
with a total of 55 occurrences. Adverse shoulder abduction was
observed a total of 30 incidences. Finally, another routinely observed
poor posture occurred for wrist extension, which was observed a total
of 29 times.
Citation: Wills AC, Devis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 7 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
Elbow
Flexion
Shoulder
Flexion
Shoulder
Abduction
Wrist
Flexion
Wrist Extension Neck Side
Bending
Back Extension Back Side
Bending
Total
All 85 (32.7%) 17
(6.5%)
30
(11.5%)
18
(6.9%)
29
(11.2%)
55
(21.2%)
11
(4.2%)
15
(5.8%)
260
Shift Type
Lunch 33 (12.7%) 6
(2.3%)
21
(8.1%)
4
(1.5%)
21
(8.1%)
20 (7.7%) 11
(4.2%)
3
(1.2%)
119
Dinner 52
(20.0%)
11
(4.2%)
9
(3.5%)
14 (5.4%) 8
(3.1%)
35 (13.5%) 0
(0.0%)
12 (4.6%) 141
Restaurant
132 (12.3%) 12
(4.6%)
13
(5.0%)
2
(0.8%)
14
(5.4%)
26
(10.0%)
5
(1.9%)
6
(2.3%)
110
220
(7.7%)
0
(0.0%)
13
(5.0%)
1
(0.4%)
11
(4.2%)
7
(2.7%)
5
(1.9%)
5
(1.9%)
61
3
Table 5: Number (Percentage of total number) of postures identied as awkward during serving.
Drinks carried
e total amount of drinks that were dropped o full and picked up
empty was 571 glasses or 167.9 glasses per hour. e plastic glasses
weighed 0.91 kg when full and 0.61 kg when empty. e bar glasses
weighed 1.14 kg when full and 0.92 kg when empty. e total amount
of full bar glasses was 178 (52.35 glasses/hour) for all three restaurants,
with restaurants 1, 2, and 3 serving 99 glasses (26.05 glasses/hour), 73
glasses (23.54 glasses/hour) and 6 glasses (1.81 glasses/hour),
respectively. e total number of plastics cups was 232 (68.23 glasses/
hour) for all three restaurants.
Physical activity
Servers at all three restaurants spent a total of 24.5% (25.5% per
hour) sitting while being observed performing their tasks, 30.9%
(13.9% per hour) of their time walking, while standing 44.6% (16.7%
per hour) of the time, according to ActivPAL. e total number of
steps per hour for all three restaurants was 609.8 steps. During the
lunch service there were a total of 609.8 steps per hour and during
dinner service there were 606.5 steps per hour. Restaurant 2 had the
most total number of steps walked at 1,327.7 steps (690.3 steps per
hour). e amount of energy expended during the working shis was
1.5 or 0.5 MET per hour, dinner shis had 0.1 MET per hour more
than the lunch shi at 0.4 MET per hour, and the dierence between
all three restaurants was 0.1 MET per hour between restaurant 3 (0.6
MET per hour) and 1(0.5 MET per hour) or 2 (0.5 MET per hour).
% of Time Sitting % of Time Standing % of Time Walking Total Number of Steps Energy Expenditure
MET▪h
All 24.5
(25.5)
44.6
(16.7)
30.9
(13.9)
1018.3
(609.8)
1.5
(0.5)
Shift Type
Lunch 15.3
(24.0)
49.4
(15.2)
35.3
(14.8)
1139.5
(609.8)
1.8
(0.4)
Dinner 33.6
(24.3)
39.9
(13.3)
26.5
(11.9)
697.1
(421.3)
1.2
(0.5)
Restaurant
123.6
(25.6)
47.4
(16.7)
29.0
(14.8)
946.7
(606.5)
1.5
(0.5)
219.2 45.0 35.8 1327.7 1.7
Citation: Wills AC, Devis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 8 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
(23.1) (12.0) (13.8) (690.3) (0.5)
327.6
(27.8)
42.2
(15.1)
30.3
(13.8)
936.0
(577.8)
1.4
(0.6)
Table 6: Physical activity for servers working as a function of overall, restaurant, and shi type (average and standard deviation).
Discussion
e current study represents one of the few studies to investigate the
ergonomic stressors for servers in restaurants. Previous research has
concentrated on musculoskeletal symptoms for servers [27] and semi-
quantitative whole body assessments like RULA [28]. e current
study adopted an observational design where servers were followed
through the entirety of their shi with objective measurement of
weight carried on trays, frequency of carrying trays, and observed
transfer technique, including awkward postures. e results showed
that when servers transferred trays, the weight carried was signicant,
averaging 6.3 kg per tray. e amount of weight per tray represents
about 73% of the average weight that has been reported for high risk
jobs in industry [6]. us, the amount of weight lied and carried
routinely by servers potentially poses signicant risk for the low back
injuries and likely shoulder problems.
Overall, the number of trays carried by the servers was about 3 per
hour, carrying 16.3 kg per hour. On the surface, this frequency seemed
to be low but maybe more reective that the observation dates were on
slow activity shis. More than half (60%) of the servers indicated that
the observed days were less busy than their typical work days. As a
result, the observed number of trays and weight carried may be
signicantly lower than typically seen for servers.
Servers spend a large percentage of their time on their feet, either
standing (45%) or walking (31%). With most of the standing and
walking occurring on hard oors either wood or concrete, long-term
detrimental eects may occur in the lower extremities and lower back
including: chronic venous insuciency [16,17], varicose veins [18,19],
low back pain [23,24] symptom free venous reux [25], hip
osteoarthritis [22], and leg and foot pain [24]. e perceptions also
support a large portion of the time spent standing or walking with 90%
of the servers indicating they stand between 5 and 8 hours per shi.
e amount of walking translated into about 1000 steps per hour.
During the observation, it is clear that the servers have frequent
periods of motion where servers are constantly running around the
restaurant getting drinks, taking orders, bringing out food, grabbing
things (e.g. ketchup or other condiments), and cashing out the bill.
Basically, the objective and subjective assessments of the standing and
walking indicate a very dynamic and physical job.
One of the main mismatches between observed and preserved
outcomes was for the amount of breaks. Based on the ActivPAL,
servers sat down about 25% of the time which would be in direct
contrast to the perceptions that indicated 55% of the servers had less
than 1 break per shi. Limited breaks could further enhance the
adverse eects of the high physical demands and being constantly on
their feet.
e other main ergonomic risk would be how the trays are handled
when delivering and returning food and dishes to the tables. e most
widely used technique to transfer the trays was holding tray directly in
front (70% of the trays transferred used the front technique). e other
two commonly observed techniques were on the shoulder (17%) and
holding hand at (7.5%). e placement of the tray at the table also
plays a role in the demands on the server. In general, servers set the
trays the majority of the time on a table (63%) or on a tray jack (17%).
Only a small portion of the trays were held throughout the serving
(20%). e use of trays or tables would certainly minimize the physical
demands on the servers with respect to holding the weight of the tray,
food and dishes.
ere may be several reasons why a server used a table instead of
the tray jacks: 1) table was more stable when setting down a tray full of
food; 2) the server was unable to grab a tray jack; and 3) transferring
the trays in front of them would make it impossible to set-up a tray
jack. Handling of the trays with food and/or dishes as well as other
activities that the servers routinely did appeared to produce awkward
postures in many of the body regions. Poor elbow postures were the
most prevalent (33% of the awkward postures) with other regions of
concern being neck (side bending-21%), wrist extension (11%), and
shoulder abduction (12%). Many of these observed awkward postures
were potentially linked to carrying and placing the trays, specically
the technique utilized. Overall, the frequency of the awkward postures
were surprising low over the observed shis, indicating that the weight
being transferred is probably a larger issue than the postures adopted
when transferring the trays and food, although the combination is the
true risk to the servers.
e physical demands of serving appeared to adversely impact the
discomfort that developed during the shis. Relatively, there were
increases in pain at the end of the shi as compared to the start in the
upper back (by 55%), neck (by 45%), lower back (by 50%), hand/wrist
(by 35%), and leg/foot ( by 60%). e increase in the pain for the
majority of the body regions appears to be linked to the physical
demands of the job such as walking/standing, frequency and weight
carried on the trays, and poor postures when handling the trays. One
of the more surprising results was the actual decrease in pain in two
regions: shoulders (by 45%) and knees (by 30%). is decrease in pain
was particularly surprising given the prevalence of holding the trays on
shoulders (relating to shoulder pain) and the extensiveness of the
standing and walking (relating to knee pain).
ere were several limitations to the study that need to be
considered when interpreting the results. First, the study was a
descriptive cross-sectional study, which limits the causal inference that
could be drawn. e observational study was also a preliminary
investigation into the demands on the servers in restaurants for a
single shi. As such, statistics were limited to descriptive statistics with
examples: 1) means per hour and 2) frequencies of events. e study
aimed to describe the potential demands, not compare between groups
such as types of restaurants, expertise, or other groupings.
Second, the study evaluated a low number of servers (n=20), each
with only one shi of observation. e main driver for the low number
of participants was the amount of time that the observations required
as a member of the research team had to directly follow the server the
entire shi. Further, several servers at the restaurants refused to
Citation: Wills AC, Devis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 9 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
participate, limiting the potential sample population. In the perfect
world, the research team would like to have had more subjects from a
more diverse group of restaurants.
ird, the number of restaurants was limited to 3 places that had
very diverse cuisine and environments. A total of 13 restaurants were
contacted with 10 refusing to allow the research team to observe. e
main concerns were the potential impact on service and the safety of
the food during observation. While methods minimized both of these,
these restaurant owners decided not to participate. In general, the
results were consistent between the dierent restaurants as well as
between lunch and dinner service, indicating that the results appear to
be robust and applicable to the broader restaurant industry. However,
the demands, liing techniques and exposures may be linked to these
restaurants and may be dierent in other facilities.
Fourth, the study only evaluated one shi per person, which
neglected variability for daily or seasonal variation. Every attempt to
minimize this biased was done by sampling on dierent days and at
dierent shis (e.g. lunch vs. dinner). e research team observed over
the entire shi, and thus, likely captured an accurate representation of
the demands on servers, although they may be under-representative of
the typical demands. e perceptions of the servers would support this
as many of the servers indicated the observed shi was less demanding
than normal.
Fih, the study population was not diverse with respect to
minorities and gender. e entire observed population was Caucasians
but we would not expect any dierence due to race. Further, the
majority of the servers were female (75%) with an average age of 26
years. us, the study population was young and relatively experienced
(averaged 4.4 years of experience). e younger population may have
reected the type of restaurants, location, or potentially the
demographic that is in this industry. A younger workforce likely
reects the typical exibility and educational level of individuals are
servers as oentimes these jobs are stepping stones to other jobs.
Sixth, the ergonomic stressors were evaluated by observations and
not directly measured by sensors or goniometers. It was not feasible to
use these more quantitative measures given the safety concerns and
time sensitive nature of serving. Observations allowed the research
team to not interfere with the servers and elevate all concerns with
food safety. Future studies need to investigate actual measurement with
devices that can be easily used and eliminate safety concerns. Further,
when a study is done, reecting oen allows you to identify things that
could have been better measured. One item that the research team has
identied as a key item was the table height when the trays where
placed on them
Seventh, the study was also evaluated in relation to pain and not
actual injuries, which requires long-term assessment. Pain provides a
short-term assessment of the negative impact of the stressors. As
indicated by Ferguson and Marras [11], musculoskeletal disorders
happen in a spectrum starting with pain and continuing to reported
injury to disability. Future studies need to look at servers longitudinally
to identify the prevalence of injuries and disabilities, thus identifying
the long-term eects.
While the study has many concerns with regard to sample size,
study design and observation methods, the study was the rst step into
understanding of demands on servers during their shis. To date, there
has been little research completed investigating the demands and
musculoskeletal disorders for servers [27,28]. Given the large number
of servers currently employed in the United States, the research
provides some insight into the weight lied and the awkward postures
adopted when serving food to the customers. Future research will need
to concentrate on better methods to more accurately capture the
physical and postural demands for servers in many dierent types of
restaurants. e bottom line is that larger and more robust studies are
needed to better understand the ergonomic and physical demands for
servers in the vast variety of restaurant environments [33-38].
Conclusion
e most notable result from the study was amount of weight lied
and carried regularly by servers (16.4 kg per hour or 6.3 kg per tray),
which theoretically poses signicant risk for the low musculoskeletal
problems. However, there are some indications that the observed
demands were below expected as more than half of the servers
indicated that the observed days were less busy than their typical work
days. us, the observed number of trays carried may be signicantly
lower than typically seen for servers impacting the servers more on
busier days. Additionally, there was a large portion of the time spent
standing or walking with 90% of the servers indicating they stand
between 5 and 8 hours per shi. Based on the ActivPAL, servers sat
down about 25% of the time which would be in direct contrast to the
perceptions that indicated 55% of the servers had less than 1 break per
shi. Limited breaks could further enhance the adverse eects of the
high physical demands and being constantly on their feet. e most
widely used technique to transfer the trays was holding tray directly in
front of the server, potentially being the more demanding tray carrying
technique. e use of trays or tables would undoubtedly minimize the
physical demands on the servers with respect to holding the weight of
the tray, food and dishes. e physical demands of serving appeared to
adversely impact the discomfort that developed during the shis.
ese awkward postures, heavy trays of food, and long periods of time
standing may take a toll on the servers. Since this is an initial study
investigating the demands of servers, there still needs more research in
order to better understand the demands required.
References
1. Bureau of Labor Statistics (2011) Occupational Employment and Wages
Waiters and Waitresses.
2. Bureau of Labor Statistics (2012) Occupational Outlook Handbook,
2012-13 Edition, Waiters and Waitresses.
3. Hales TR, Bernard BP (1996) Epidemiology of work-related
musculoskeletal disorders. See comment in PubMed Commons below
Orthop Clin North Am 27: 679-709.
4. Davis KG, Marras WS (2000) Assessment of the relationship between box
weight and trunk kinematics: Does a reduction in box weight necessarily
correspond to a decrease in spinal loading? Human Factors 42: 195-208.
5. Kelsey JL, Githens PB, White AA, Holford TR, Walter SD, et al. (1984) An
epidemiologic study of liing and twisting on the job and risk for acute
prolapsed lumbar intervertebral disc. See comment in PubMed
Commons below J Orthop Res 2: 61-66.
6. Marras WS, Lavender SA, Leurgans SE, Rajulu SL, Allread WG et al.
(1993) e role of dynamic three-dimensional motion in occupationally-
related low back disorders. the eects of workplace factors, trunk
position, and trunk motion characteristics on risk of injury. Spine 18:
617-628.
7. Neumann WP, Wells RP, Norman RW, Frank J, Shannon H et al. (2001) A
posture load sampling approach to determining low-back pain risk in
occupational settings, International Journal of Industrial Ergonomics 27:
65-77.
8. Hoogendoorn WE, Bongers PM, de Vet HC, Douwes M, Koes BW, et al.
(2000) Flexion and rotation of the trunk and liing at work are risk
Citation: Wills AC, Devis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 10 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
factors for low back pain: results of a prospective cohort study. See
comment in PubMed Commons below Spine (Phila Pa 1976) 25:
3087-3092.
9. Ferguson SA, Marras WS (1997) A literature review of low back disorder
surveillance measures and risk factors. See comment in PubMed
Commons below Clin Biomech (Bristol, Avon) 12: 211-226.
10. Myers AH, Baker SP, Li G, Smith GS, Wiker S, et al. (1999) Back injury in
municipal workers: a case-control study. American Journal of Public
Health 89: 1036-1041.
11. Marras WS, Lavender SA, Leurgans SE, Fathallah FA, Ferguson SA, et al.
(1995) Biomechanical risk factors for occupationally related low back
disorders. See comment in PubMed Commons below Ergonomics 38:
377-410.
12. Jansen JP, Morgenstern H, Burdorf A (2004) Dose-response relations
between occupational exposures to physical and psychosocial factors and
the risk of low back pain. See comment in PubMed Commons below
Occup Environ Med 61: 972-979.
13. Miranda H, Viikari-Juntura E, Martikainen R, Takala EP, Riihimäki H
(2002) Individual factors, occupational loading, and physical exercise as
predictors of sciatic pain. See comment in PubMed Commons below
Spine (Phila Pa 1976) 27: 1102-1109.
14. Tubach F, Leclerc A, Landre MF, Pietri-Taleb F (2002) Risk factors for sick
leave due to low back pain: a prospective study. See comment in PubMed
Commons below J Occup Environ Med 44: 451-458.
15. Van Nieuwenhuyse A, Somville PR, Crombez G, Burdorf A, Verbeke G et
al. (2006) e role of physical workload and pain related fear in the
development of low back pain in young workers: evidence from the
BelCoBack Study; results aer one year of follow up. Occupational and
Environmental Medicine 63: 45-52.
16. Krijnen RM, de Boer EM, Adèr HJ, Bruynzeel DP (1997) Venous
insuciency in male workers with a standing profession. Part 2: diurnal
volume changes of the lower legs. See comment in PubMed Commons
below Dermatology 194: 121-126.
17. Krijnen RM, de Boer EM, Ader HJ, Bruynzeel DP (1997) Venous
insuciency in male workers with a standing profession. Part 1:
epidemiology. Dermatology, 194: 111-120.
18. Fowkes FG, Evans CJ, Lee AJ (2001) Prevalence and risk factors of
chronic venous insuciency. See comment in PubMed Commons below
Angiology 52 Suppl 1: S5-S15.
19. Tomei F, Baccolo TP, Tomao E, Palmi S, Rosati MV (1999) Chronic
venous disorders and occupation. See comment in PubMed Commons
below Am J Ind Med 36: 653-665.
20. Sisto T, Reunanen A, Laurikka J (1995) Prevalence and risk factors of
varicose veins in lower extremities: mini-Finland health survey. European
Journal of Surgery 161: 405-414.
21. Labropoulos N, Delis KT, Nicolaides AN (1995) Venous reux in
symptom-free vascular surgeons. See comment in PubMed Commons
below J Vasc Surg 22: 150-154.
22. Cro P, Cooper C, Wickham C, Coggon D (1992) Osteoarthritis of the
hip and occupational activity. See comment in PubMed Commons below
Scand J Work Environ Health 18: 59-63.
23. Ryan GA (1989) e prevalence of musculo-skeletal symptoms in
supermarket workers. See comment in PubMed Commons below
Ergonomics 32: 359-371.
24. Macfarlane GJ, omas E, Papageorgiou AC, Cro PR, Jayson MI, et al.
(1997) Employment and physical work activities as predictors of future
low back pain. See comment in PubMed Commons below Spine (Phila Pa
1976) 22: 1143-1149.
25. Gregory DE, Callaghan JP (2008) Prolonged standing as a precursor for
the development of low back discomfort: an investigation of possible
mechanisms. See comment in PubMed Commons below Gait Posture 28:
86-92.
26. Nelson-Wong E, Howarth SJ, Callaghan JP (2010) Acute biomechanical
responses to a prolonged standing exposure in a simulated occupational
setting. Ergonomics 9: 1117-1128.
27. Dempsey PG, Filiaggi AJ (2006) Cross-sectional investigation of task
demands and musculoskeletal discomfort among restaurant wait sta. See
comment in PubMed Commons below Ergonomics 49: 93-106.
28. Jones T, Strickfaden M, Kumar S (2005) Physical demands analysis of
occupational tasks in neighborhood pubs. See comment in PubMed
Commons below Appl Ergon 36: 535-545.
29. Scherrer MD, Wilder DA (2008) Training to increase safe tray carrying
among cocktail servers. See comment in PubMed Commons below J Appl
Behav Anal 41: 131-135.
30. McAtamney L, Nigel Corlett E (1993) RULA: a survey method for the
investigation of work-related upper limb disorders. See comment in
PubMed Commons below Appl Ergon 24: 91-99.
31. Aminian S, Hinckson EA (2012) Examining the validity of the ActivPAL
monitor in measuring posture and ambulatory movement in children.
See comment in PubMed Commons below Int J Behav Nutr Phys Act 9:
119.
32. Cameron JA (1996) Assessing work-related body-part discomfort:
Current strategies and a behaviorally oriented assessment tool.
International Journal of Industrial Ergonomics 18: 389-398.
33. Bildt C, Alfredsson L, Michélsen H, Punnett L, Vingard E, et al. (2000)
Occupational and nonoccupational risk indicators for incident and
chronic low back pain in a sample of the Swedish general population
during a 4-year period: An inuence of depression?. International Journal
of Behavioral Medicine 7: 372-392.
34. Bureau of Labor Statistics, USA Department of Labor, Survey of
Occupational Injuries and Illnesses in cooperation with participating
State agencies.
35. Hoogendoorn WE, van Poppel MN, Bongers PM, Koes BW, Bouter LM
(1999) Physical load during work and leisure time as risk factors for back
pain. See comment in PubMed Commons below Scand J Work Environ
Health 25: 387-403.
36. Josephson M, Vingard E (1998) Workplace factors and care seeking for
low-back pain among female nursing personnel. MUSIC-Norrtälje Study
Group. See comment in PubMed Commons below Scand J Work Environ
Health 24: 465-472.
37. Tissot F, Messing K, Stock S (2009) Studying the relationship between low
back pain and working postures among those who stand and those who
sit most of the working day. See comment in PubMed Commons below
Ergonomics 52: 1402-1418.
38. Tüchsen F, Krause N, Hannerz H, Burr H, Kristensen TS (2000) Standing
at work and varicose veins. See comment in PubMed Commons below
Scand J Work Environ Health 26: 414-420.
Citation: Wills AC, Davis KG, Kotowski SE (2016) Quantification of Ergonomic Exposures for Restaurant Servers . J Ergonomics Open Access:
166. doi:10.4172/2165-7556.1000166
Page 11 of 11
J Ergonomics
ISSN:2165-7556 ${journalCode} Volume Open Access • Issue 3 • 1000166
... increasing prevalence of work-related issues including fatigue 3) , anxiety, and burn-out 50 syndrome 4) as well as the realization that metabolic heat can lead to significant health and 51 productivity decrements 5) . It is not surprising, therefore, that current occupational guidelines 52 highlight the importance of EC assessment during work for the workers' health and safety, for 53 prevention of physical and mental illness, as well as for the development of corrective action 54 plans 6,7) . ...
... As a result, several health-related issues have emerged in occupational settings, such as burn-244 out syndrome 4) and work exhaustion 3) , that need to be considered. In addition, one of the most 245 immediate and obvious effects of climate change is the increase in environmental temperatures 246 and workers are already affected since many workplaces are becoming very hot 79,5) . ...
... corresponding to the job types assessed in two studies 2,3) which monitored a total of 98 workers. ...
Article
Full-text available
The assessment of energy cost (EC) at the workplace remains a key topic in occupational health due to the ever-increasing prevalence of work-related issues. This review provides a detailed list of EC estimations in jobs/tasks included in tourism, agriculture, construction, manufacturing, and transportation industries. A total of 61 studies evaluated the EC of 1667 workers while performing a large number of tasks related to each one of the aforementioned five industries. Agriculture includes the most energy-demanding jobs (males: 6.0 ± 2.5 kcal/min; females: 2.9 ± 1.0 kcal/min). Jobs in the construction industry were the 2nd most demanding (males: 4.9 ± 1.6 kcal/min; no data for females). The industry with the 3rd highest EC estimate was manufacturing (males: 3.8 ± 1.1 kcal/min; females: 3.0 ± 1.3 kcal/min). Transportation presented relatively moderate EC estimates (males: 3.1 ± 1.0 kcal/min; no data for females). Tourism jobs demonstrated the lowest EC values (2.5 ± 0.9 kcal/min for males and females). It is hoped that this information will aid the development of future instruments and guidelines aiming to protect workers' health, safety, and productivity. Future research should provide updated EC estimates within a wide spectrum of occupational settings taking into account the sex, age, and physiological characteristics of the workers as well as the individual characteristics of each workplace.
... In their study, 42 % musculoskeletal, the lower back area (18%) and shoulder (11%) symptoms were experienced. Wills et al. (2016) analysed physical discomfort and ergonomic stress that restaurant server's exposure. As researchers analysed upper back is the greatest discomfort (55%) body region during the shift. ...
Article
Full-text available
This study aims to investigate ergonomic risk factors and improve the process in hotel enterprises. The research focused on the main operational process such as food preparation, material supply, and warehouse, in the kitchen, housekeeping and warehouse departments. In the first step, a checklist is prepared according to ILO, OSHA, NIOSH and IEA documents. In this checklist job tasks, workstations and working environment are subject to the study. After controlled by industry experts checklist implemented and results show that there are some ergonomic risk factors in the kitchen. In order to improve the ergonomic conditions 2³, (3 factors, 2 level) factorial design was put into practice. Results show that the greatest effect is caused by Factor 2 (presence of underfoot mat) comes first, Factor 1 (height of the workbench is at elbow level) comes second and Factor 3 (job rotation) comes third.
Article
Background: Physical and psychosocial demands (e.g., serving, cleaning, fulfilling orders) can lead to work-related musculoskeletal pain (WRMSP). Objective: To assess the prevalence of WRMSP in the upper quadrant and lower back among skilled male Arab waiters; to evaluate the disability related to WRMSP; to evaluate the association between work demands and WRMSP with related disability. Methods: 100 skilled male Arab waiters working full-time, aged 18-60, participated in the cross-sectional study. Participants completed basic demographics and working conditions; the NDI; QuickDASH; the OswestryQ; workload, burnout, and job satisfaction at work; the adjusted NordicQ; and the TaskQ, compiled especially for this study. Results: A 12-month pain prevalence, pain frequency, and work avoidance were high: neck- 42%, 60.5%, 89.5% ; shoulders -53%, 78.2%, 94.4% ; elbows- 46%, 78.6%, 83.3% ; lower back- 45%, 44%, 78.7%, respectively. Pain prevalence in at least one site was 83% . The OswestryQ, QuickDASH, and NDI revealed mild-moderate pain and disability (14.85/50, 25.54/75, 13.74/50, respectively). Burnout score was positively associated with OswestryQ, QuickDASH, and NDI. Job satisfaction was negatively associated with 12 months of pain in the lower back, hands, arms, shoulders, and hands (NordicQ). TaskQ was positively associated with OswestryQ. Conclusion: Male Arab waiters who work in physically and psychologically challenging conditions report high levels of WRMSP with a high frequency and related work avoidance. Many of them must keep their jobs as they are their families' primary or sole providers. It is possible that they are trying to prevent more severe disabilities in the future by ensuring temporary rest and pain prevention.
Conference Paper
Full-text available
Serving staff are an integral part of restaurant establishments. Although over 2.2 million individuals are employed as wait staff in the US and experience a considerable number of musculoskeletal disorders each year, little is known about their work-related risk factors for MSDs. Using observational methods, a physical activity monitor, and surveys, this study quantified the physical demands experienced by servers over a shift. Twenty wait staff were evaluated for postures used during serving, tray weight, pain symptoms, and perceived workload. Results showed increases (upwards of 60%) in pain throughout their shift, substabtial time spent standing or walking (~75%), and potentially risky arm/wrist postures during serving, even though a majority of servers indicated lighter than normal workloads during the observation period. While further research is needed, this study provides a first glimpse at the physical demands experienced by wait staff.
Article
Full-text available
Decreasing sedentary activities that involve prolonged sitting may be an important strategy to reduce obesity and other physical and psychosocial health problems in children. The first step to understanding the effect of sedentary activities on children’s health is to objectively assess these activities with a valid measurement tool. To examine the validity of the ActivPAL monitor in measuring sitting/lying, standing, and walking time, transition counts and step counts in children in a laboratory setting. Twenty five healthy elementary school children (age 9.9 ± 0.3 years; BMI 18.2 ± 1.9; mean ± SD) were randomly recruited across the Auckland region, New Zealand. Children were fitted with ActivPAL monitors and observed during simulated free-living activities involving sitting/lying, standing and walking, followed by treadmill and over-ground activities at various speeds (slow, normal, fast) against video observation (criterion measure). The ActivPAL sit-to-stand and stand-to-sit transition counts and steps were also compared with video data. The accuracy of step counts measured by the ActivPAL was also compared against the New Lifestyles NL-2000 and the Yamax Digi-Walker SW-200 pedometers. We observed a perfect correlation between the ActivPAL monitor in time spent sitting/lying, standing, and walking in simulated free-living activities with direct observation. Correlations between the ActivPAL and video observation in total numbers of sit-to-stand and stand-to-sit transitions were high (r = 0.99 ± 0.01). Unlike pedometers, the ActivPAL did not misclassify fidgeting as steps taken. Strong correlations (r = 0.88-1.00) between ActivPAL step counts and video observation in both treadmill and over-ground slow and normal walking were also observed. During treadmill and over-ground fast walking and running, the correlations were low (r = 0.21-0.46). The ActivPAL monitor is a valid measurement tool for assessing time spent sitting/lying, standing, and walking, sit-to-stand and stand-to-sit transition counts and step counts in slow and normal walking. The device did not measure accurately steps taken during treadmill and over-ground fast walking and running in children.
Article
Full-text available
The objectives of this study were to examine the relation between occupational and nonoccupational conditions and both incident (IBLP) and chronic low back pain (CLBP), aswellasdepression, among women and men. Data from a4-year follow-up of a study group consisting of 420 participants of both genders from the general Swedish population were analysed. Occupational risk indicators were predictors for both ILBP and CLBP. Depression was not found to be a predictor for either IBLP or CLBP among women, but was a predictor for CLBP among men. Among women, depression had some risk indicators in common with ILBP and appeared to be a concurrent outcome rather than a risk indicator. Low back pain in 1993 was not a predictor for depression in 1997 in either women or men. Occupational conditions are of relevance in relation to both incident and CLBP. Nonoccupational conditions were stronger predictors for CLBP than for ILBP but had some predictive value also for ILBP.
Article
Full-text available
Prolonged occupational standing has previously been associated with low back pain (LBP) development. The immediate effects of a bout of prolonged standing on subsequent functional movement performance have not been investigated. It is possible that including a period of prolonged standing may have acute, detrimental effects. The purpose of the study is to investigate the impact of a prolonged standing exposure on biomechanical profiles (trunk muscle activation, joint stiffness and kinematics) during three functional movements. A total of 23 volunteers without history of LBP performed lumbar flexion, single-leg stance and unloaded squat movements pre- and post 2 h of standing exposure. It was found that 40% of the participants developed LBP during the standing exposure. There was a decrease in vertebral joint rotation stiffness in lateral bending and increased centre of pressure excursion during unilateral stance following standing exposure. There may be adverse effects to prolonged standing if followed by activities requiring precise balance or resistance of side loads. STATEMENT OF RELEVANCE: Prolonged standing may result in decreases in balance reactions during narrow base conditions as well as in the capacity to effectively resist side-loads at the trunk. Consideration should be given when prolonged standing is included in the workplace.
Article
Full-text available
A relationship between low back pain (LBP) and prolonged standing or prolonged sitting at work has not been clearly shown, despite its biological plausibility. Because sitting and standing postures vary as to duration and freedom to alternate postures, and standing postures vary as to mobility, associations between specific working postures and LBP were explored using multiple logistic regression. Associations between work factors and self-reported LBP during the previous 12 months that interfered with usual activities were examined among 4493 standing workers and 3237 sitting workers interviewed in the 1998 Quebec Health and Social Survey; 24.5% reported significant LBP. Since the same conditions can correspond to different physiological demands for sitting compared with standing workers, analyses were performed separately for the two groups. Standing without freedom to sit was associated with LBP. Different occupational physical and psychosocial factors were associated with LBP in sitting compared with standing populations.
Article
Objectives Low-back pain is common among nursing personnel, and its origin is multifactorial. The present study focused on physical and psychosocial work load. The objectives of the study were to estimate the relative risk for nursing personnel, compared with other occupational groups, to seek health care for low-back pain, and to identify risk factors. Methods This study is a part of a population-based case-referent study in the municipality of Norrtalje, situated north of Stockholm. Altogether 333 women served as cases and 733 served as referents. Eighty-one cases and 188 referents were employed in nursing work. The cases had sought health care for low-back pain during the study period, November 1993 to November 1996. The referents were randomly selected from the same population. The subjects filled out 2 questionnaires and participated in interviews about physical exposures and psychosocial factors. Results When the female nursing personnel were compared with other employed women, no increased risk of consultation for low-back pain was found. According to a multivariate logistic regression, nursing personnel exposed to forward-bending working positions, high energetic work load, perceived physical exertion, or insufficient social support had the highest risk estimates. In univariate analyses, the combination of physical and psychosocial risk factors was associated with a particularly high risk. Conclusions In nursing work, physical load seems to be more significant than psychosocial factors when a worker seeks health care for low-back pain. The results of did not support the hypothesis that nursing work is a risk occupation for seeking care for low-back pain when compared with other occupations.
Article
Background: Chronic venous insufficiency (CVI) in the occupational population is often poorly recognized. The dimensions of this problem have never been thoroughly investigated in the Netherlands. Objective: To study the epidemiology and risk factors of CVI in males with a standing position at work. To develop a simple diagnostic instrument for screening an (occupational) population for CVI. Methods: 387 male workers with a standing profession were examined by means of a questionnaire, physical examination, Doppler ultrasound investigation, light reflection rheography and optical leg volume measurements. Results: CVI was present in 29% of the subjects and correlated with age, weight and duration of standing work. Complaints of the legs were reported by 81% of the individuals with CVI but also by 63% of the persons without CVI. The questionnaire had a predictive value of 80% in detecting CVI. Conclusion: CVI was a major problem because of the quantity (29%) and the accompanying complaints. Neither the questionnaire nor other investigative measures proved to be as efficient in diagnosing CVI as physical examination in combination with Doppler ultrasound investigation.
Article
A posture and load sampling approach to measure physical exposures was implemented within a case-control study of low-back pain reporting. The purpose of this paper was to determine how well this method was able to identify known low-back pain risk factors. Subjects, including both cyclic production and non-cyclic support workers, were studied while working in an automotive assembly facility. The study included 104 (with 20 proxies) cases, workers who reported low-back pain at work, and 129 randomly selected controls. Results indicate significant associations between low-back pain reporting and peak spinal loads (OR=2.0 for compression), shift-average spinal loading (OR=1.7 for compression), percent of time with loads in the hand (OR=1.5), maximum flexion angle (OR=2.2), and percent of time spent forward flexed beyond 458(OR=1.3). Posture and hand load variables, considered to be intermediate exposure variables, were handled separately in multivariable regression analyses from variables of peak and average spine force which directly estimate tissue loading. The work and posture sampling approach is particularly useful for heterogeneous work situations where traditional task analysis is difficult and can provide information on work and tissue load parameters which have been directly associated with risk of reporting low-back pain. Relevance to industry This paper demonstrates the effectiveness of an observational method in quantifying workplace exposures to physical risk factors for low-back pain. The method works for both cyclic and non-cyclic work. Quantified risk assessment provides key information for decision makers trying to control injury rates in industrial systems. # 2001 Elsevier Science B.V. All rights reserved.
Article
Work-related body-part discomfort has been assessed for a variety of purposes in both experimental and applied research. In a number of these studies, ‘discomfort’ is assessed using a body map and a rating, or ranking, procedure. Sometimes the assessed values are subjected to direct statistical investigation; at other times the assessed values are used to derive indices of discomfort which are then subjected to statistical study. However, the construct of ‘discomfort’ is rarely clearly defined. Thus, depending on the nature of the investigation, the respondent's perceptions, and the instructions provided, it may incorporate a variety of physical sensations including pain, fatigue, tension, and tingling. This paper describes ways in which work-related body-part discomfort has been defined, assessed, and used. It concludes with a tool for assessing work-related body-part discomfort. This tool includes a body map and scales for assessing the severity, frequency, and duration of work-related body-part discomfort, and incorporates many of the key features identified in this literature review.
Article
This case-referent study investigated the relation between hip osteoarthritis and occupational activity. The subjects were 60- to 75-year-old men who had undergone intravenous urography. Interviews were obtained for 245 cases who had a hip replacement for osteoarthritis or a joint space of less than or equal to 2.5 mm and 294 referents whose joint space was greater than or equal to 3.5 mm in both hips. No clear associations were found in an analysis of all the cases, but severe disease (hip replacement for osteoarthritis or a joint space of less than or equal to 1.5 mm) was more common in the farmers, especially in those with greater than or equal to 10 years in agricultural work [odds ratio (OR) 2.0, 95% confidence interval (95% CI) 0.9-4.4]. Severe disease was also associated with prolonged standing at work (OR 2.7, 95% CI 1.0-7.3) and heavy lifting (OR 2.5, 95% CI 1.1-5.7). These associations could not be explained by obesity or sporting activity. The findings suggest an increased risk of degenerative hip disease for farmers and indicate that mechanical overloading may contribute to its pathogenesis.
Article
The Victorian Branch of the Shop Distributive and Allied Employees Association became concerned in 1985 by the large number of cases of musculo-skeletal symptoms being reported by members working in food and grocery supermarkets. With the support of the Victorian Occupational Health and Safety Commission a survey was carried out which was aimed at determining the prevalence of such symptoms, and identifying associated factors. A questionnaire designed to establish the presence of musculo-skeletal symptoms was administered to all employees of seven supermarkets ranging in size from 15 to 171 employees, with a response rate of 73%. The staff of supermarkets were predominantly young, female and transient. One-third reported regular symptoms in some part of their body. Prevalence rates were calculated for body area and department. The checkout department had the highest rates for almost all body areas. The lower back, lower limbs and feet were the body areas with the highest rates. Postures and activities of a sample of job categories in each department were sampled at 10 s intervals for periods of 30 min for a total of 1000 observations for each department. A positive and significant correlation was found between proportion of time spent standing and symptoms in the lower limb and foot, especially in the checkout department where 90% of the time was spent standing in one place. It was concluded that there was an excess of symptoms appearing in checkout operators, and therefore, the operating methods of the checkout department warrant revision.