Content uploaded by Raj Bawa
Author content
All content in this area was uploaded by Raj Bawa on Dec 11, 2015
Content may be subject to copyright.
.
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 135
Nanoparticle-based Therapeutics in Humans:
A Survey
RAJ BAWA
∗
ABSTRACT
With patent expirations on the rise, pharmaceutical and biotechnology companies are searching for
new competitive business strategies. There is enormous excitement regarding nanomedicine’s potential
impact in the diagnostic and therapy arenas. Specifically, drug delivery via nanoparticles presents novel
therapeutic opportunities for active agents (drugs or genes) that were previously unsuited to traditional
oral or injectable therapeutic formulations, allowing active agents to be delivered efficaciously while
minimizing side effects and leading to better patient compliance. Nanoparticle-based therapeutics have
enormous potential in addressing the failures of traditional therapeutics that could not be effectively
formulated due to factors such as poor water solubility or a lack of target specificity. Although there are
only a few FDA-approved nanoparticle-based therapeutics on the market, these formulations are already
impacting medicine and promise to alter healthcare. The initial impact of nanoparticle-based
therapeutics will likely only accelerate in the coming years. However, as these products move out of the
laboratory and into the clinic, federal agencies like the FDA and the U.S. Patent and Trademark Office
continue to struggle to encourage the development of these products while imposing some sort of order.
To date, numerous nanoparticles including luminescent quantum dots, magnetic nanoparticles, gold
nanoshells, dendrimers, and block copolymer micelles have been studied for drug delivery. In this
article, Dr. Raj Bawa provides a brief overview of different nanoparticle technologies with some
comments on their commercialization potential. In particular, he highlights selected nanoparticle-based
therapeutics that are undergoing clinical trials or have been approved for human use.
∗
Dr. Raj Bawa is president of Bawa Biotechnology Consulting LLC, a biotechnology and patent firm founded in
2002 and based in Ashburn, Virginia. He is a registered patent agent licensed to practice before the U.S. Patent and
Trademark Office and specializes in all aspects of biotechnology, chemical, nanotechnology, and pharmaceutical
patent law. Currently, Dr. Bawa is an Adjunct Associate Professor at Rensselaer Polytechnic Institute in Troy, New
York, where he is also Advisor to the Office of Technology Commercialization. He is a Life Member of Sigma Xi,
a Fellow and Board Member of the American Academy of Nanomedicine, and serves on the Global Advisory
Council of the World Future Society. Presently, he serves on the editorial boards of the peer-reviewed journals,
International Journal of Nanomedicine and Nanotechnology Law and Business. He is an Associate Editor of the
peer-reviewed journal, Nanomedicine: Nanotechnology, Biology and Medicine. Dr. Bawa can be contacted at:
Bawa Biotechnology Consulting, LLC, 21005 Starflower Way, Ashburn, Virginia 20147, USA (Tel: 703-582-1745;
703-723-0034; Fax: 571-223-1844; Email: bawabio@aol.com). The author declares that there is no conflict of
interest. Nothing contained herein should be construed as rendering legal advice or expressing an opinion regarding
the merits of a particular company or product.
Bawa
136 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
I. THE DRUG DISCOVERY PROCESS
rug companies in today’s global economy face enormous pressure to deliver high-quality
products to the consumer while maintaining profitability. They must constantly reassess how to
improve the success rate of new molecular entities (NMEs) while reducing research and
development (R&D) costs and cycle time associated with producing new drugs, especially new
blockbusters. In fact, the cost of developing and launching a new drug to the market, although widely
variable, may be upwards of 800 million U.S. dollars.
1
Typically, the drug appears some 10 to 15 years
after discovery.
2
Furthermore, out of 5,000 compounds that enter preclinical testing, only five lead
compounds make it to human testing and just one makes it to final clinical use.
3
Annual R&D investment
by drug companies has risen from one billion U.S. dollars in 1975, to 40 billion today—while annual new
approvals have remained flat at between 20-30 drugs.
4
Big pharma’s business model, which relies on a
few blockbusters to generate profits via enormous promotional campaigns, is clearly broken. Moreover,
in recent years, patents on numerous blockbusters have been expiring. In fact, drug revenues worth 70-80
billion U.S. dollars will be lost by 2011 as various drugs go off-patent. This is altering the drug landscape
in a big way.
Some argue that big pharma is too focused on shareholder profits rather than innovative therapies.
A recent study shows that big pharma spends twice as much on promotion as R&D.
5
Drug companies are
also facing other challenges that necessitate development and implementation of novel R&D strategies.
6
Given this backdrop, there is a critical need for drug companies to alter research approaches and
business models so that they can continue to discover and fill the pipeline with novel compounds and
introduce them to new markets. Therefore, it is not surprising that drug companies today are focusing on
technologies that support high-throughput, miniaturization and nanotechnology,
7
which enable faster drug
target discovery and drug development.
1
P
HARMACEUTICAL
D
OSAGE
F
ORMS AND
D
RUG
D
ELIVERY
1
(Ram Mahato ed.,
CRC Press, 2007).
2
See R. Anon, Health Informatics Into the 21st Century. H
EALTH
C
ARE
R
EP
.
F
EB
.:
R
EUTERS
B
US
.
I
NSIGHT
(1999)
3
See id.; See also John Erickson, Translation Research and Drug Development, 312 S
CI
. 997 (2006).
4
See Norman L. Sussman & James H. Kelly, Saving Time and Money in Drug Discovery – A Pre-emptive
Approach, B
US
.
B
RIEFINGS
:
F
UTURE
D
RUG
D
ISCOVERY
46 (2003), available at
http://www.touchbriefings.com/pdf/16/Sussman.pdf.
5
See Marc-Andre Gagnon & Joel Lexchin, The Cost of Pushing Pills: A New Estimate of Pharmaceutical
Promotion Expenditures in the United States, 5 PL
O
S
M
ED
. 29 (2008).
6
The industry is currently facing other hurdles as well, including: increasing costs for drug development (only
30% of drugs ever recover their R&D costs); weakened product pipelines; decreasing numbers of new drugs
approved by the FDA and foreign drug agencies; an increase in the generics’ share of the prescription drug market;
international competition from countries like China and India; voluntary or forced withdrawal of several
blockbusters; difficulty in delivering promising biomolecules, such as, peptides, proteins and other therapeutic
biologicals (generated as a result of the rapid growth of the global biotechnology industry); pricing pressures due to
high industry margins; a sharp decline in public confidence in the pharma industry; state and federal government’s
increased vigilance pertaining to hyper-aggressive business practices (e.g., illegal drug marketing and improper drug
pricing); difficulty or inability in effectively formulating active agents (30–40% of all active agents identified via
combinatorial screening programs have poor water solubility). On top of all this, the FDA and the U.S. Patent &
Trademark Office (PTO) are in crisis. See Raj Bawa, Nanotechnology Patent Proliferation and the Crisis at the U.S.
Patent Office, 17 A
LB
.
L.
J.
S
CI
.
&
T
ECH
.
699 (2007). Both federal agencies are plagued by quality and performance
issues—lack of expertise and talent in certain technology areas; a high turnover; poor morale; and inadequate
computer systems. See id. at 721-28.
7
One of the problems facing nanotechnology is the confusion, hype and disagreement among experts about its
definition. One of the most quoted, yet inaccurate, definition of nanotechnology is the one used by the U.S.
National Nanotechnology Initiative (NNI): “. . . the understanding and control of matter at dimensions of roughly 1
to 100 nanometers, where unique phenomena enable novel applications.” National Nanotechnology Initiative, What
D
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 137
In theory, nanotechnology
8
should reduce the cost of drug discovery, design, and development. It
should enhance the drug discovery process itself through miniaturization, automation, speed, massive
parallelism, and reliability of assays. The resulting improved R&D success rate should enable faster
introduction of new, cost-effective products to the marketplace leading to enhanced business revenues in
the future. For example, nanotechnology can be applied to current microarray technologies, exponentially
increasing the hit rate for promising candidates/targets that can be screened and accelerating the
generation of novel NMEs. Inexpensive and higher throughput DNA sequencers based on
nanotechnology can reduce the time for both drug discovery and diagnostics.
In reality, nanotechnology is offering solutions to fundamental problems in the drug industry ranging
from poor solubility to a lack of target specificity. In fact, numerous companies are already
commercializing nanomaterials and nanosystems for various biomedical applications.
As high-throughput screening technologies continue to lead to an increase in the number of poorly
water-soluble NMEs, drug nanoparticle formulations have been proposed (see Sections II and III) and
utilized (see Tables 1-3) to tackle such formulation problems as well. Furthermore, nanoscience research
has also uncovered a need for novel analytical technologies that can directly impact aspects of therapeutic
delivery, such as determining target efficacy and therapeutic outcome.
This article will focus on engineered nanoparticle-based therapeutics pertaining to the drug delivery
arena. The toxicity, biocompatibility (e.g., the interactions between engineered nanoparticles and
biological systems) and health-related issues of nanoparticles due to instability (either too rapid
degradation or prolonged stability within the body) are topics left to a future article.
is Nanotechnology? http://www.nano.gov/html/facts/whatIsNano.html (last visited May 31 2008). This definition
excludes numerous devices and materials of micrometer dimensions, a scale that is included within the definition of
nanotechnology by many. Government agencies such as the FDA and the PTO also use a definition based on a scale
of less than 100 nm—this rigid definition is essentially copied from the NNI. However, this NNI definition of
nanotechnology presents difficulties not only for understanding nanopatent statistics, but also for the proper
assessment of scientific, legal, environmental, regulatory, and ethical implications of nanotechnology. This problem
exists because nanotechnology represents a cluster of technologies, each of which may have different characteristics
and applications. For example, although the sub-100 nm size range may be critical for a nanophotonic company
where quantum effects depend on particle size (e.g., quantum dot size dictates the color of light emitted therefrom),
this size limitation is not critical to a drug company from a formulation, delivery or efficacy perspective because the
desired or ideal property (e.g., improved bioavailability, reduced toxicity, lower dose, enhanced solubility, etc.) may
be achieved in a size range greater than 100 nm. Numerous examples from the pharmaceutical industry highlight
this important point (see Tables 1 and 2). In view of this confusion, a more practical definition of nanotechnology,
unconstrained by an arbitrary size limitation, has recently been proposed: “The design, characterization, production,
and application of structures, devices, and systems by controlled manipulation of size and shape at the nanometer
scale (atomic, molecular, and macromolecular scale) that produces structures, devices, and systems with at least
one novel/superior characteristic or property.” Raj Bawa, Special Report - Patents and Nanomedicine, 2(3)
N
ANOMED
. 351 (2007).
8
Governments across the globe are impressed by nanotechnology’s potential and are staking their claims by
doling out billions of dollars, euros, and yen for research. According to a recent report, governments, corporations
and venture capitalists in 2005 spent almost 10 billion U.S. dollars on nanotechnology R&D globally while
emerging nanotechnology was incorporated into more than 30 billion U.S. dollars of manufactured goods. L
UX
R
ESEARCH
, T
HE
N
ANOTECH
R
EPORT
,
4th ed.
(2006). This report predicts that by 2014, 2.6 trillion U.S. dollars in
global manufactured goods may incorporate nanotechnology (about 15% of total output). U.S. federal funds are
supplemented by state investments in nanotechnology (approximately 40 cents per U.S. dollar). The President’s
budget for 2008 allocated 1.44 billion U.S. dollars for nanotech as compared to 1.35 billion U.S. dollars in 2007.
Bawa
138 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
II. NANOPARTICLES AS THERAPEUTIC AGENTS
Often, the efficacy and commercial viability of a drug depends upon its mode of delivery. This fact
is highlighted by the existence of hundreds of specialty pharmaceutical companies whose focus is to
develop innovative drug delivery systems (DDS).
9
A long-standing issue for drug companies is to deliver
the correct dose of a particular therapeutic (small molecules, proteins, or nuclei acids) to a specific disease
site. Since this is generally unachievable, therapeutics have to be administered in excessively high doses,
thereby increasing the odds of toxic side effects. The concept of site-specific delivery of a therapeutic
arises from this classic drawback of traditional therapeutics. Nanoparticles have enormous potential in
addressing this failure of traditional therapeutics: they offer site-specific targeting of therapeutics. Such
precision targeting via therapeutic nanoparticles will reduce systemic side effects, resulting in better
patient compliance. Various approaches involving targeted multivalent drug nanoparticles are under
investigation or on the horizon.
10
Indeed, nanotechnology is poised to deliver to the marketplace
evolutionary as well as revolutionary products.
11
Some of these products could be available immediately
while others are on the distant horizon.
12
Nanoparticles are selected for properties such as biodegradability, biocompatibility, conjugation,
complexation or encapsulation properties and their ability to be functionalized. There are two types of
nanoparticle-based therapeutic formulations: (1) those where the therapeutic molecules are the
nanoparticles (therapeutic functions as its own carrier); and (2) those where the therapeutic molecules are
directly coupled (functionalized, entrapped or coated) to a carrier.
9
DDS are polymeric (or lipid) carrier systems that transport a therapeutic (e.g., drug or gene) to its target binding
site (receptor, active site, etc.) so as to impart maximum therapeutic activity with maximum safety (i.e., protect the
body from adverse reactions) while preventing the degradation/denaturation/inactivation of the therapeutic during
delivery/transit. Targeting can be achieved by (a) linking specific ligands or molecules (e.g., antibodies,
glycoproteins, etc.) to the carrier system; or (b) altering the surface characteristics of the carrier system so that it
evades the reticuloendothelial (RES) system.
10
See Austin M. Derfus et al., Remotely Triggered Release From Magnetic Nanoparticles, 19 A
DVANCED
M
ATERIALS
3932 (2007), available at http://lmrt.mit.edu/publications/DerfusAdvMat2007.pdf; Wim H. De Jong &
Paul Borm, Drug Delivery and Nanoparticles: Applications and Hazards, 3(2) I
NT
’
L
J.
OF
N
ANOMED
. 133 (2008);
See also D
EEPAK
T
HASSU ET AL
.,
N
ANOPARTICULATE
D
RUG
D
ELIVERY
S
YSTEMS
(Informa Healthcare USA 2007);
T
UAN
V
O
-D
INH
,
N
ANOTECHNOLOGY IN
B
IOLOGY AND
M
EDICINE
:
M
ETHODS
,
D
EVICES
,
AND
A
PPLICATIONS
(CRC
Press 2007).
11
See Raj Bawa,
T
HE
F
UTURE OF
N
ANOMEDICINE
266 (T. C. Mack ed., World Future Society 2007).
12
The U.S. demand for drug delivery systems will increase by more than 10% annually to 132 billion U.S. dollars
in 2012. See Bill Martineau, Demand for Novel Drug Delivery Systems Rising, 28 G
ENETIC
E
NG
’
G
&
B
IOTECH
.
N
EWS
14 (2008), available at http://www.genengnews.com/articles/ chitem.aspx?aid=2474. The U.S. demand for
nanotech-related medical products is expected to increase by more than 17 percent per year to 53 billion U.S. dollars
in 2011 and 110 billion U.S. dollars in 2016. See The Freedonia Group, Nanotechnology in Healthcare to 2011
(2007). Nanotechnology-enabled drug delivery systems will generate over 4.8 billion U.S. dollars in 2012. See
Antonio Regalando, Nanotechnology Patents Surge as Companies Vie to Stake Claim, W
ALL
S
TREET
J, June 18,
2004 at A1, available at http://www.signallake.com/innovation/061804WSJNanotechPatentsSurge.htm. The market
for the use of nanotechnology-enabled drug delivery in 2005 was 1.3 billion U.S. dollars, with a 35% annual growth
rate projected for the next five years. See Clare Kittredge, FDA Seeks ‘Little’ Information, T
HE
S
CIENTIST
, June 1,
2006 at 78. As of mid-2006, 130 nanotech-based drugs and delivery systems and 125 devices or diagnostic tests
were in preclinical, clinical, or commercial development. See supra note 8. The U.S. National Science Foundation
predicts that nanotechnology will produce half of the pharmaceutical industry product line by 2015. Id.
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 139
1.
What are Therapeutic Nanoparticles?
Nanoparticles are colloidal particles of approximately 10 nanometers to 1,000 nanometers (1
micron) in size and widely used in drug delivery.
13
Nanoparticles are diverse both in their shape and
composition. Many of the properties of nanomaterials are fundamentally different from those of their
macroscopic/bulk analogues due to an increased surface area and quantum effects. As a particle’s size
decreases, a greater proportion of its atoms are located on the surface relative to the interior (core), often
rendering it more reactive. In fact, these “quantum effects” coupled with these “surface area effects” can
affect optical, electrical, chemical and magnetic properties of nanomaterials, which in turn can affect their
in vivo behavior. Therefore, nanopartice-based therapeutics, often offer an advantage
14
as compared to
their bulk counterparts due to one or more parameter or property.
15
It is important to note that there are numerous engineered nanoparticles of varying architectures that
can act as platforms for therapeutics. Since there is no universal convention or nomenclature that
classifies nanoparticles as perfect spherical structures with nanoscale dimensions, various nanoscale
structures are sometimes loosely classified as nanoparticles. In fact, some of the common shapes include
spheres (hollow or solid), tubules, particles (solid or porous), and tree-like branched macromolecules.
16
Nanoparticles are synthesized by various methods (self-assembly, vapor or electrostatic deposition,
aggregation, nano-manipulation, imprinting, etc.) where the specific protocol is dictated by factors like
the specific therapeutic used and the desired delivery route. The critical characteristics of a nanoparticle
related to its function include size, surface charge, encapsulation efficiency and release properties.
2.
Applications of Therapeutic Nanoparticles
Oral delivery of actives via polymeric delivery carriers and systems is the primary mode of
therapeutic delivery. However, it is well established that traditional oral therapeutics are not necessarily
the most efficient formulations for a given active.
17
In this regard, note that 8-10% of an oral therapeutic
is either denatured by the stomach environment or eliminated via liver metabolism. Therefore, targeting
therapeutics to the site of action by circumventing this metabolism will have numerous advantages, such
as reduction of unwanted side effects, reduced toxicity due to lowered dose requirement, enhanced patient
13
See Paul R. Lockman et al., Nanoparticle Technology for Drug Delivery Across the Blood-Brain Barrier, 28
D
RUG
D
EV
.
&
I
NDUS
.
P
HARMACY
1 (2002).
14
Some of these parameters or properties include: solubility (high surface to bulk ratio), bioavailability, half-
life/stability/shelf life, ability to penetrate biological barriers/membranes, toxicity/safety/patient compliance, patient
fasted versus fed variability, delivery dose, catalytic properties, imaging, multifunctionality, site-specific
delivery/targeting, pharmacokinetics/timed release/controlled release, surface structure/chemistry/modification, drug
distribution, and physical properties (i.e., color, transparency, magnetism, and quantum effects).
15
See e.g., Raj Bawa & Mark Haymann, Solid Biodegradable Nanoparticles for Drug Delivery, I
NT
’
L
J.
OF
N
ANOMED
. (in press 2008); See also Masayuki Yokoyama, Drug Targeting with Nano-Sized Carrier Systems, 8 J.
A
RTIFICIAL
O
RGANS
77 (2005); Barrett E. Robinow, Nanosuspensions in Drug Delivery, 3 N
ATURE
R
EV
.
D
RUG
D
ISCOVERY
785 (2004); Jean-Christophe Oliver, Drug Transport to Brain with Targeted Nanoparticles, 2
N
EURO
R
X
108 (2005); S. Moein Moghimi et al., Nanomedicine: Current Status and Future Prospects, 19 FASEB
J.
311 (2005), available at http://www.fasebj.org/cgi/content/short/19/3/311; Celeste Roney et al., Targeted
Nanoparticles for Drug Delivery Through the Blood-Brain Barrier for Alzheimer’s Disease, 108 J.
C
ONTROLLED
R
ELEASE
193 (2005) ; See also supra note 10.
16
Examples of nanoparticles of varying architectures that can act as platforms for therapeutics include:
nanocrystals/colloidal dispersions, quantum dots, nanoshells, dendrimers, liposomes, micelles (polymeric micelles,
cylindrical worm micelles), polymersomes, cyclodextrins, magnetic nanoparticles, nanosphere hydrogels, fullerenes,
and nanocochleate delivery vehicles.
17
See Dwaine F. Emerich & Christopher G. Thanos, The Pinpoint Promise of Nanoparticle-Based Drug Delivery
and Molecular Diagnosis, 23 B
IOMOLECULAR
E
NG
’
G
171 (2006).
Bawa
140 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
compliance, greater therapeutic effectiveness, economic benefits, etc. This is the motivation for major
research projects in recent years focusing on oral nanoparticles.
Nanoparticles are also better suited than their microparticle counterparts for intravenous (IV)
delivery because the tiniest capillaries are in the 5-6 micron range, a size that impedes most
microparticles (or aggregations thereof) from entering these capillaries. It is generally accepted that for
systemic applications, nanoparticles should be in the range of 10-100 nanometers, with minimum surface
charge.
18
Specifically, these properties permit systemic circulation and determine its biodistribution
within the human body. It is this size regime that allows more effective systemic circulation than smaller
molecules and access to places in the human body where larger particles cannot reach. For example,
chemotherapeutic-tagged nanoparticles of specific size can penetrate tumors due to the “leaky” nature of
their microvasculature. This classic effect, referred to as the “enhanced permeation and retention (EPR)
effect”, results in prolonged circulation and accumulation of a therapeutic within the tumor.
Nanoparticles can also be used for getting drugs into the brain. The blood-brain barrier (BBB) is a
dynamic endothelial interface which has a unique structure due to the presence of tight junctions.
In fact,
98% of drugs are unable to transverse the BBB.
19
However, nanoparticle drug delivery is particularly
useful for disorders of the central nervous system (CNS) because some nanoparticles are able to cross this
BBB.
20
Often, nanoparticle drugs can be delivered directly to the CNS without prior need for drug
modification or functionalization (which can affect efficacy). Moreover, both hydrophilic and
hydrophobic drugs may be delivered without first opening the BBB. Obviously, nanoparticles delivered
systemically for non-CNS diseases are of general concern because they may cross the BBB and cause
brain toxicity or psychoactive effects.
Nanoparticles can also permeate the tight epithelial junctions of the skin that normally impede
delivery of drugs to the desired target.
21
Topical emulsion systems incorporating nanoparticles are being
developed which rapidly permeate tissue to deliver actives or remove lethal toxins from the blood stream.
Generally, by controlling the size and architecture of nanoparticles, a particular pharmacokinetic
release profile of the drug can be generated. Often, a near zero-order kinetic drug release profile is
desired since it maintains a steady drug concentration at the site of delivery. Such a profile is more likely
to be achieved by nanoparticles where a drug has been functionalized onto or encapsulated within a
carrier polymer matrix. Various technologies employ just such an approach where polymeric
nanoparticles serve as “Trojan horses” and have been functionalized via a variety of NMEs (see Tables 1-
3). Furthermore, such surface-modifications of drug-loaded nanoparticles often prevent their rapid
clearance by phagocytes following IV delivery. For oral applications of nanoparticles, research has
focused on lymphatic uptake of nanoparticles by the Peyer’s patches of the gut-associated lymphoid tissue
(GALT). It has been shown that during oral drug delivery of drug loaded nanoparticles, the nanoparticles
are disseminated systemically while their microparticle counterparts remain in the Peyer’s patches.
22
Particle size has an impact in another way also. The efficiency of drug distribution within various
body cavities is influenced, in part, by the size of the drug particles. As the particle size of a drug
18
See Mark E. Davis, Nanoparticles for Systemic Medicines and Imaging Agents, 3 N
ANOTECH
.
L.
&
B
US
. 255
(2006).
19
See William M. Pardridge, Brain Drug Targeting: The Future of Brain Drug Development, 3 M
OLECULAR
I
NTERVENTIONS
90 (2003).
20
See Giovanni Tosi et al., Polymeric Nanoparticles for the Drug Delivery to the Central Nervous System, 5
E
XPERT
O
PIN
.
D
RUG
D
ELIVERY
155 (2008).
21
See supra notes 10 and 11
22
See M. D. Blanco & M. J. Alonso, Development and Characterization of Protein-Loaded Poly (Lactide-Co-
Glycolide) Nanosphers, 43 E
UR
.
J.
P
HARMACEUTICS
&
B
IOPHARMACEUTICS
287 (1997).
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 141
decreases, its total surface area increases exponentially (see Figure 1). This reduction in particle size
increases its dissolution rate and saturation solubility, which frequently correlates to improved in vivo
drug performance.
23
In some cases, the pharmacokinetic behavior of nanoparticle drugs may help
minimize peak plasma levels (which may be toxic) as well as prevent a drop below the targeted
therapeutic range (which may reduce efficacy).
Finally, it should be noted that imaging or sensing agents may additionally be incorporated into a
nanodelivery system to generate multifunctionality (e.g., drug-loaded quantum dots).
III. NANOPARTICLE-BASED THERAPEUTICS—A SURVEY
It is known that drugs with poor bioavailability often result in higher cost to the consumer, not to
mention inefficient treatment and increased risk of toxicity. Ironically, as stated earlier (Section I), due to
the high-throughput technologies available today, there has also been an increase in the number of
potential NMEs that are poorly water soluble.
24
In recent years various nanoparticle technologies have
been successfully employed to tackle drugs with low water and/or lipid solubility.
25
In fact, numerous
pharmaceutical companies are revisiting shelved drugs that were “difficult” from a formulation point-of-
view due to their solubility profiles. They are starting to rely more on nanotechnology companies to
address their formulation challenges.
All nanoparticulate nanomedicines currently on the market have been approved by the FDA
according to preexisting laws (see Tables 1-3). Although the FDA has not required any special testing of
nanoparticle-based therapeutics (e.g., with respect to their pharmacokinetic profiles), there are not many
marketed nanoparticle-based therapeutics (see Tables 1-3). This is an obvious consequence of the
extremely complex and demanding requirements of clinical trials by the FDA. There are, however,
numerous nanoparticle-based therapeutics under development.
26
Below, I will highlight some nanoparticle-based therapeutics that are either approved for sale by the
FDA (listed in Tables 1 and 3) or are presently in various phases of clinical trials (listed in Table 2):
23
See Robinow supra note 15; See also Vandana B. Patravale et al., Nanosuspensions: A Promising Drug
Delivery Strategy, 56 J.
P
HARMACY
&
P
HARMACOLOGY
827 (2004).
24
See e.g., Chris A. Lipinski, Poor Aqueous Solubility: An Industry Wide Problem in Drug Discovery, 5 A
M
.
P
HARMACY
R
EV
. 82 (2002); Magdalene Radtke, Pure Drug Nanoparticles for the Formulation of Poorly Soluble
Drugs, 3 N
EW
D
RUGS
62 (2001).
25
See e.g., Radtke supra note 24; See also R
AINER
H.
M
ULLER
&
B
ERNHARD
H.
L.
B
OHM
, N
ANOSUSPENSIONS
149
(Rainer H. Muller et al., eds., Medpharm Scientific Pubs. 1998); Elaine Marisko-Liversidge et al., Nanosizing: A
Formulation Approach for Poorly Water-Soluble Compounds, 18 E
UR
.
J.
P
HARMACEUTICAL
S
CI
.
113 (2003); See
also U.S. Patent No. 5,145,684 (issued Sep. 8, 1992).
26
See e.g., R
AJ
B
AWA
,
P
ATENTING
I
NVENTIONS IN
B
IONANOTECHNOLOGY
:
A
P
RIMER FOR
S
CIENTISTS AND
L
AWYERS
309 (David E. Reisner ed., CRC Press, 2008); See Bawa & Hayman supra note 15; See also supra notes
10 and 11; Op ed., Top Ten Nanoparticle Drug Patents, 5 N
ANOTECH
.
L.
&
B
US
. 111 (2008); R
AJ
B
AWA
&
S.
R.
B
AWA
,
P
ROTECTING
N
EW
I
NVENTIONS IN
N
ANOMEDICINE
31 (Cynthia G. Wagner ed., World Future Society Press,
2005); Laura Mazzola, Commercializing Nanotechnology, 21 N
ATURE
B
IOTECH
. 1137 (2003); Robert Paull et al.,
Investing in Nanotechnology, 21 N
ATURE
B
IOTECH
. 1144 (2003); Robert A. Freitas Jr., What is Nanomedicine? 1
N
ANOMED
. 2 (2005).
Bawa
142 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
1. Elan Corporation—NanoCrystal Technology
27
Because consumers prefer oral drugs over implantables or injectables, nano-engineering traditional
or shelved compounds could greatly enhance oral bioavailability in some cases. A classic example of
improving the bioavailability of poorly soluble drugs is Ireland-based Elan Corporation’s NanoCrystal
technology. This technology is: (a) an enabling technology for evaluating NMEs that exhibit poor water
solubility and/or (b) a valuable tool for optimizing the performance of current drugs. According to Elan,
NanoCrystal technology can be incorporated into both parenteral and oral dosage forms. The particles are
produced by proprietary attrition-based wet-milling techniques that reduce the size of drug particles to
less than 1,000 nanometers.
28
This reduction in size substantially increases the particle’s surface area,
hence, increasing the solubility (see Figure 1). The nanosized drug particles are then stabilized against
agglomeration by surface adsorption of selected GRAS (Generally Regarded As Safe) stabilizers.
29
This
results in a final product that behaves like a solution (a colloidal dispersion). Studies have shown that
reformulating old drugs by this technology can enhance bioavailability compared to commercial
products
30
, reduce the time to achieve maximum concentration, as well as result in an increase in the
“area under the curve” (AUC) during the first hour.
31
Elan’s technology may enable an increase in drug
loading, thereby enhancing the maximum tolerated dose compared to commercial products.
32
Typically
speaking, drug nanocrystals imply a crystalline state of the discrete particles. Unlike polymeric
nanoparticles, they lack any polymeric matrix material.
It should be pointed out that reformulation of an existing therapeutic into a nanoparticulate version
generally results in a novel NME because it usually displays an altered pharmacokinetic profile (altered
AUC and C
max
) as compared to its parent (larger) counterpart. In other words, nanoparticulate
therapeutics are generally not bioequivalent to their parent (larger) counterparts and hence, cannot apply
for FDA approval via an Abbreviated New Drug Application (ANDA) route. But, if the nanoparticulate
formulation is bioequivalent to its parent (larger) version, an ANDA can be filed to seek regulatory
approval.
The solid-dosage tablet formulation of the immunosuppressant Rapamune (sirolimus, Wyeth
Pharmaceuticals; FDA approval in 2000) is the first marketed drug developed with NanoCrystal
technology and the first commercial launch of a nanoparticulate therapeutic. Some other examples of
reformulated, FDA-approved drugs that employ this technology are TriCor (fenofibrate, Abbot
Laboratories; FDA approval in 2004) and Emend (aprepitant, Merck & Co.; FDA approval in 2003). It is
interesting to note that the variability observed in the fasted and fed patients upon administration of
Abbot’s micronized TriCor was not observed upon administration of the reformulated nanoparticulate
formulation. Table 3 provides the complete listing of marketed nanoparticulate products developed via
Elan’s NanoCrystal technology.
27
See U.S. Patent No. 5,145,684 (issued Sep. 8, 1992); U.S. Patent No. 5,302,401 (issued April 12, 1994); U.S.
Patent No. 5,399,363 (issued March 21, 1995); U.S. Patent No. 5,494,683 (issued Feb. 27, 1996); U.S. Patent No.
5,552,160 (issued Sep. 3, 1996); U.S. Patent No. 5,569,448 (issued Oct. 29, 1996).
28
See Marisko-Liversidge supra note 25.
29
See id.
30
See Gary G. Liversidge & Kenneth C. Cundy, Particle Size Reduction for Improvement of Oral Bioavailability
of Hydrophobic Drugs: I. Absolute Oral Bioavailability of Nanocrystalline Danazol in Beagle Dogs, 125 I
NT
’
L
J.
P
HARMACEUTICS
91 (1995).
31
See id.; see also Gary G. Liversidge & P. Conzentino, Drug Particle Size Reduction for Decreasing Gastric
Irritancy and Enhancing Absorption of Naproxen in Rats, 125 I
NT
’
L
J.
P
HARMACEUTICS
309 (1995).
32
See Elaine Marisko-Liversidge et al., Formulation and Antitumor Activity Evaluation of Nanocrystalline
Suspensions of Poorly Soluble Anticancer Drugs, 13 P
HARMACEUTICAL
R
ES
. 272 (1996).
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 143
2. Abraxis BioScience, Inc.—Paclitaxel-Albumin Nanoparticles
33
Abraxane is an albumin-bound nanoparticle formulation of the widely used anticancer drug,
Paclitaxel (Taxol). It is the only albumin-bound solvent-free taxane nanoparticulate formulation (~130
nm) that takes advantage of albumin to transport Paclitaxel into tumor cells. It was approved by the FDA
in 2005 for use in patients with metastatic breast cancer who have failed combination therapy (Table 1).
Because Abraxane is free of toxic solvents typically associated with other approved Paclitaxel
preparations, there is no need for pre-medication with steroids or antihistamines often needed to prevent
these side effects. Another advantage is that it is administered in 30 minutes, as compared to three hours
for solvent-based Paclitaxel. Note that albumin is a protein that acts as the body’s natural carrier of
molecules that are poorly water soluble. Two different proteins actively transport and concentrate
albumin within tumors: gp60 found on the surface of the endothelial cells and SPARC found on the
surface of many tumor cells.
At the molecular level, Paclitaxel induces abnormal arrays of cell microtubules by preventing
depolymerization. The recommended dose for Abraxane is 260 mg/m
2
administered intravenously over
30 minutes, every three weeks. As of March 2008, Abraxane is approved for use in 33 countries and is
under active review in Australia, Russia, Korea and China. Abraxane is marketed in the U.S. under a co-
promotion agreement between Abraxis BioScience, Inc. and AstraZeneca Pharmaceuticals LP. Currently,
Abraxane is being evaluated for other cancers, including advanced non-small-cell lung cancer
34
and
ovarian cancer.
35
3. Nanospectra Biosciences—AuroShell Particles
36
AuroShell particles (previously known as Nanoshells) were developed by Drs. Naomi Halas and
Jennifer West of Rice University in the 1990s which eventually led to the formation of Nanospectra
Biosciences. Formal operations began in 2002 to commercialize applications using AuroShell particles
(Table 2). Nanospectra has obtained FDA approval to commence human trial for the treatment of head
and neck cancers. According to Nanospectra, AuroShell particles are a new type of optically tunable
particles composed of a dielectric core coated with an ultra-thin metallic layer. For their oncology
applications a silica core is surrounded by an ultra-thin gold shell (gold-coated glass nanoparticles).
The optical properties of AuroShell particles depend dramatically on the relative sizes of the core
and the thickness of the metal shell. In fact, this core-shell structure can be smaller than a wavelength of
33
See e.g., Neil Desai et al., Increased Antitumor Activity, Intratumor Paclitaxel Concentrations, and Endothelial
Cell Transport of Cremophor-Free, Albumin-Bound Paclitaxel, ABI-007, Compared with Cremophor-Based
Paclitaxel, 12 C
LINICAL
C
ANCER
R
ES
. 1317 (2006); William J. Gradishar et al., Phase III Trial of Nanoparticle
Albumin-Bound Paclitaxel Compared with Polyethylated Castor Oil-Based Paclitaxel in Women with Breast
Cancer, 23 J. CLINICAL ONCOLOGY 7794 (2005); PDR
S
TAFF
,
D
RUG
I
NFORMATION FOR THE
H
EALTH
C
ARE
P
ROFESSIONAL
, 25th ed. (Micromedex Thomson Healthcare 2005); Abraxis Oncology, Package Insert: Abraxane
for Injectable Suspension (Paclitaxel Protein-Bound Particles for Injectable Suspension) (2005); U.S. Patent No.
6,096,331 (issued Aug. 1, 2000); U.S. Patent No. 5,362,478 (issued Nov. 8, 1994); U.S. Patent No. 5,439,686
(issued Aug. 5, 1995); U.S. Patent No. 5,498,421 (issued March 12, 1996); U.S. Patent No. 5,665,382 (issued Sep.
9, 1997); U.S. Patent No. 5,916,596 (issued June 29, 1999).
34
See M. R. Green et al., Abraxane, A Novel Cremophor-Free, Albumin-Bound Particle Form of Paclitaxel for the
Treatment of Advanced Non-Small-Cell Lung Cancer, 17 A
NNALS OF
O
NCOLOGY
1263 (2006).
35
John P. Micha et al., Abraxane in the Treatment of Ovarian Cancer: The Absence of Hypersensitivity Reactions,
100 G
YNECOLOGIC
O
NCOLOGY
437 (2006).
36
See D. Patrick O’Neal et al., Photo-Thermal Tumor Ablation in Mice Using Near Infrared-Absorbing
Nanoparticles, 209 C
ANCER
L
ETTERS
, 171 (2004); Christopher Loo et al., Nanoshell-Enabled Photonics-Based
Imaging and Therapy of Cancer, 3 T
ECH
.
C
ANCER
R
ES
.
T
REATMENT
33 (2004); S. J. Oldenburg et al., Infrared
Extinction Properties of Gold Nanoshells, 75 A
PPLIED
P
HYS
.
L
ETTERS
2897 (1999); U.S. Patent No. 6,645,517
(issued Nov. 11, 2003); U.S. Patent No. 6,685,730 (issued Feb. 3, 2004).
Bawa
144 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
light (“nano-scale” optics). The relative core size as well as the shell thicknesses can be varied, thereby
altering the optical properties of AuroShell particles across a broad range of the electromagnetic spectrum
(including the visible and the infrared regions). It is this ability to “tune” AuroShell particles to a desired
wavelength that is critical to in vivo therapeutic applications. For example, gold particles generally
absorb light in the green region of the visible spectra, but when used as the shell of an AuroShell particle
they can be “engineered” to interact with near-infrared or other wavelengths—dramatically shifting the
optical properties of the particle.
AuroShell particles are injected intravenously and specifically collect in the tumor through the
characteristically leaky vasculature via the classic EPR effect (see Section II, part 2). Generally,
AuroShell particles of size ~150 nm are considered ideal for this application. Following accumulation of
AuroShell particles in a tumor, the area is illuminated with a near-infrared laser at wavelengths chosen to
allow the maximum penetration of light through tissue, converting the laser light into heat. The metal in
AuroShell particles converts absorbed light into heat with high efficiency, thereby acting as “heat
generators” and cooking or destroying a tumor from within. Human blood and tissue minimally absorb
certain near-infrared wavelengths of light, enabling lasers to deliver light through human tissue to
AuroShell particles that have selectively accumulated in a tumor. Theoretically, the technology could be
useful for the eradication of any solid tumor, including cancers of the breast, prostate and lung. It is
worth pointing out that the toxicity of gold remains to be fully investigated.
4. Calando Pharmaceuticals, Inc.—RONDEL Technology
37
Calando Pharmaceuticals, Inc. is a privately held biopharmaceutical company funded by Arrowhead
Research Corporation.
38
The company has developed proprietary therapeutic cyclodextrin-containing
polymer RNA interference (RNAi) delivery technology and demonstrated the first clear in vivo sequence-
specific gene inhibition in tumors. RNAi is a naturally occurring mechanism within cells for selectively
silencing and regulating genes. Since many diseases are caused by malfunctioning genes, the ability to
silence and regulate such genes selectively through RNAi could provide a means to treat a wide range of
human diseases. According to the company, such systemic delivery through the bloodstream raises the
prospect for broad application of RNAi therapeutics to treat a wide range of cancers and other systemic
diseases.
Calando’s technology for RNAi is called RONDEL. Specifically, it employs small interfering RNA
(siRNA) as the therapeutic RNA. siRNAs are double-stranded RNAs that are targeted to a specific
disease-associated gene because they are complementary to this gene. Calando’s cyclodextrin-containing
polymers are a two-part siRNA delivery system: a linear, cyclodextrin-containing polycation that binds to
the anionic “backbone” of the siRNA. Following this, the polymer and siRNA self-assemble into
nanoparticles (~50 nm). The cyclodextrin fully protects the siRNA from enzymatic degradation in serum.
Furthermore, cyclodextrin enables the surface of the nanoparticles to be decorated via stabilizing agents
and targeting ligands. According to the company, the surface-modifying agents have terminal
adamantane groups that form inclusion complexes with the cyclodextrin and contain polyethylene glycol
(PEG) to endow the particles with properties that prevent aggregation while increasing stability. Ligands
37
See Suzie Hwang Pun & Mark E. Davis, Development of a Nonviral Gene Delivery Vehicle for Systemic
Application, 13 B
IOCONJUGATE
C
HEM
.
630 (2002); Derek W. Bartlett & Mark E. Davis, Impact of Tumor-Specific
Targeting and Dosing Schedule on Tumor Growth Inhibition After Intravenous Administration of siRNA-Containing
Nanoparticles, 99 B
IOTECH
.
&
B
IOENG
’
G
975 (2008); U.S. Patent No. 6,509,323 (issued Jan. 31, 2003); U.S. Patent
No. 7,270,808 (issued Sep. 18, 2007).
38
Earlier this year, Arrowhead Research Corporation completed the merger between Insert Therapeutics, Inc. and
Calando Pharmaceuticals, Inc. as part of a streamlining of the two companies in which Arrowhead assumed active
management. The merged company is doing business under the name “Calando Pharmaceuticals, Inc.”
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 145
to cell surface receptors can be covalently attached to the adamantane-PEG modifier, enabling the
siRNA-containing nanoparticles to be targeted to specific tissues (see Figure 2).
Calando’s nanoparticle delivery system is designed for IV injection. According to the company,
upon delivery of the RNA-containing nanoparticles, the targeting ligand binds to membrane receptors on
the targeted cell surface enabling the nanoparticles to be taken up into the cell via endocytosis. Once
inside, the siRNA is released from its cyclodextrin delivery vehicle. It then binds to the disease-
associated gene, preventing its replication and ability to cause disease. Importantly, Calando’s delivery
system does not produce an interferon-mediated immune response often associated with lipid delivery of
siRNA, even if known immunostimulatory motifs are included in the siRNA.
In April 2008, the FDA approved Calando’s application for an investigational new drug (IND) for its
lead anti-cancer compound, CALAA-01 (see Table 2). This drug candidate is a targeted nanoparticle,
comprising a non-chemically-modified siRNA against the M2 subunit of ribonucleotide reductase (a
clinically-validated cancer target). This approval allows Calando to undertake a Phase I trial, the first
clinical study using targeted, systemic delivery of siRNA in an oncology setting.
5. Starpharma Holdings, Ltd.—Dendrimer-based VivaGel
39
Starpharma Holdings Limited,
40
a leader in the development of dendrimer nanotechnology products,
is principally composed of two operating companies, Starpharma Pty. Ltd. and Dendritic
Nanotechnologies, Inc. Products based on Starpharma’s dendrimer technology are already on the market
in the form of diagnostic elements and laboratory reagents. Starpharma’s lead nanopharmaceutical
development product is VivaGel (SPL7013 Gel) which is based on a dendrimer (Table 2). VivaGel is a
topical vaginal microbicide for the prevention of HIV and genital herpes. It also has activity against
clinically relevant human papillomavirus and also shows promise as a contraceptive agent. VivaGel has
been successfully tested in a Phase I clinical trial, and phase II trials are currently underway. VivaGel has
been granted Fast Track status by the FDA. In addition, in May 2008, the company reported positive
results of a clinical trial that achieved all its objectives demonstrating that 3% VivaGel was safe and well-
tolerated in sexually abstinent women when administered vaginally, twice daily for 14 days. In addition
to the gel application, Starpharma has an agreement with SSL (the makers of Durex) to co-develop
VivaGel-coated Durex condoms.
Dendrimers are precisely defined, synthetic nano-size tree-like macromolecules with branching
emanating from a central core (“branched nanoparticles”). They were developed in the late 1970s by Drs.
Fritz Vögtle (University of Bonn, Germany) and Donald Tomalia (then at Dow Chemical in Midland,
Michigan). Dendrimers are synthesized around a central initiator core unit with each subsequent growth
step representing a new layer of polymer resulting in a larger molecular diameter, twice the number of
reactive surface sites, and approximately double the molecular weight of the preceding generation.
Specifically, dendrimer synthesis begins with a central initiator core unit with the successive addition of
new layers (“generations”) to the branching groups. The selection of core, branching and surface
molecules gives the dendrimer the desired properties and applications (see Figures 3(a) and 3(b)).
39
See Tom D. McCarthy et al., Dendrimers as Drugs: Discovery and Preclinical and Clinical Development of
Dendrimer-Based Microbicides for HIV and STI Prevention, 2 M
OLECULAR
P
HARMACEUTICS
312 (2005); U.S.
Patent No. 5,714,166 (issued Feb. 3, 1998).
40
In October 2006, Starpharma Holdings Ltd. acquired US-based Dendritic Nanotechnologies, Inc. expanding the
company’s potential product line. See Starpharma, Home Page, http://www.starpharma.com. In April 2008,
Starpharma announced the first commercial product launch based on its Priostar
dendrimer technology. See
Starpharma, Press Release: April 22, 2008, http://www.starpharma.com/data/080422%20First%20commercial
%20product%20launch%20DNT%20Priostar%20dendrimers.pdf. This product, developed under a license and
supply agreement established in February 2007 between DNT and EMD Chemicals Inc., is a research reagent kit
known as NanoJuice Transfection Kit and is for transporting DNA into cells. Id.
Bawa
146 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
Furthermore, “polyvalency” can be introduced in a dendrimer by arranging multiple copies of an active
group onto its surface. This is important because simultaneous presentation of an active group can result
in new or enhanced activity as compared to single presentation of the same active group. This specialized
chemistry used to make and modify dendrimers allows the chemist to control the physical and chemical
properties of each dendrimer.
6. Mersana—Fleximer-Camptothecin Conjugate
41
Mersana Therapeutics, Inc. (formerly Nanopharma Corp.) is a privately held, venture backed
company that utilizes its proprietary nanotechnology platform to transform existing and experimental
anti-cancer agents into new, patentable drugs with superior pharmaceutical properties. Mersana’s key
component of this platform is a “stealth” material derived from dextran called Fleximer. Fleximer is a
biodegradable, hydrophilic and multivalent polymer that can be chemically linked to small molecules and
biologics to enhance their pharmacokinetics and safety. It was developed by Dr. Mikhail Papisov of
Massachusetts General Hospital.
Mersana’s lead product candidate includes XMT-1001 (a Fleximer-camptothecin
42
conjugate where
the polymer serves as a scaffold) is currently in Phase 1 clinical trials for cancer (see Table 2). XMT-
1001 is a broad-spectrum cytotoxic that utilizes a novel, dual release mechanism to liberate the
camptothecin prodrug, which is then converted within cells into camptothecin, a DNA topoisomerase I
inhibitor. According to the company, in preclinical studies, XMT-1001 was better tolerated and more
efficacious than either camptothecin or irinotecan in models of human cancer, showing extended plasma
half-life and high concentrations in tumor tissue. It produced the same pharmacokinetic profile as seen in
animals, gradually releasing the drug in a non-toxic form. Phase II trials in two solid tumor indications
are planned for this year.
According to Mersana, its Fleximer platform has led to several collaborations in applications that are
not suited to standard liposome or PEG approaches. These include a recombinant protein replacement
therapy, an active tumor-targeting peptide, and a nucleic acid that inhibits a pathogenic protein.
IV. COMMERCIALIZATION POTENTIAL OF NANOPARTICLE-BASED
THERAPEUTICS
Commercialization activities in nanomedicine are currently driven by startups and small and
medium enterprises (SMEs). Universities are also pushing their basic nanoscience into real products.
43
However, it is imperative that most, if not all, of these organizations eventually partner and rely upon
biotech or drug companies to make their enterprises a business success. They do, however, face the
41
See Alexander Yurkovetskiy et al., XMT-1001, A Novel Polymeric Prodrug of Camptothecin, is A Potent
Inhibitor of LS174 and A2780 Human Tumor Xenografts in a Mouse Model (2007) (Abstract 781 on file at
Mersana), available at http://www.mersana.com/library/user_files/XMT-
1001__a_novel_polymeric_prodrug_of_camptothecin_071107.pdf; Claudette Bethune et al., Pharmacokinetics of A
Novel Camptothecin Conjugate (XMT-1001) in the Rat and Dog (2007) (Abstract 4723 on file at Mersana),
available at http://www.mersana.com/library/ user_files/
Pharmacokinetics_of_a_novel_camptothecin_conjugate_070907.pdf; Mikhail I. Papisov et al., Semisynthetic
Hydrophilic Polyals, 6
B
IOMACROMOLECULES
2659 (2005); Alexander Yurkovetskiy et al., Fully Degradable
Hydrophilic Polyals for Protein Modification, 6 B
IOMACROMOLECULES
2648 (2005).
42
Camptothecins are a class of anticancer agents that inhibit DNA topoisomerase I but manifest cystitis and were
not further developed. Camptothecin homologs such as Topotecan (Hycamtin, GSK) and Irinotecan (Camptosar,
Pfizer) have more than one billion U.S. dollars in annual revenues combined.
43
Ann M. Thayer, Building Businesses, 86(22) C
HEM
.
&
E
NG
’
G
N
EWS
10 (2008), available at
http://pubs.acs.org/cen/coverstory/86/8613cover.html.
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 147
daunting task of impressing and convincing biotech and drug companies to partner with them in light of
the fact that few commercially viable products are around. Moreover, investors have also been cautious
as to what route, if any, the FDA will take in regulating nanomedicines in the future.
So far, the process of converting basic research in nanomedicine into commercially viable products
has been difficult. In the future, several variables will determine whether advances in the laboratory will
translate into commercial products available in the clinic. Presently, multiple challenges and risks beset
the commercialization of nanoparticle-based therapeutics.
44
Moreover, securing valid and defensible patent protection will also be critical to any
commercialization effort.
45
Sadly, the proliferation of nanoparticle patent applications filed at the U.S.
Patent & Trademark Office (PTO), coupled with the continued issuance of surprisingly broad patents by
the PTO, is creating a chaotic, tangled patent landscape where competing players are unsure as to the
validity and enforceability of numerous issued patents.
46
If this trend continues, it could stifle
competition and limit access to some patented inventions. On the other hand, a robust patent system will
aid drug companies that are striving to develop commercially viable nanoparticle products because valid
patents stimulate market growth and innovation, generate revenue, prevent unnecessary licensing and
greatly reduce the need for infringement lawsuits. Therefore, it is hoped that desperately needed reforms
to overhaul the PTO and the decades-old U.S. patent system,
47
along with clearer regulatory guidelines
from the FDA regarding nanoparticle-based therapeutics, will be forthcoming.
In spite of all these challenges, the market impact of nanoparticle therapeutics on the pharmaceutical
and biotech industries will be widely felt, ranging from new specialized treatments for exotic diseases to
reengineered common over-the-counter drugs. Novel or reformulated nanoparticle delivery systems will
even disrupt the generic drug market. Furthermore, based on their ability to reduce time-to-market,
extend the economic life of proprietary drugs
48
and create additional revenue streams, nanoparticle-based
44
Some of the commercialization challenges for nanoparticle-based therapeutics are:
(a) lack of quality control; (b) nanoparticle separation from undesired nanostructures like byproducts, catalysts, and
starting materials; (c) scalability issues; (d) enhancing the production rate; (e) reproducibility from batch to batch
with respect to particle size distribution, charge, porosity, and mass; (f) high fabrication costs; (g) lack of knowledge
regarding the interaction between therapeutic nanoparticles and living cells (the issue of biocompatibility and
toxicity); (h) nanoparticle optimization for maximum therapeutic potential; (i) the public’s general reluctance to
embrace innovative medical technologies without government-sanctioned safety guidelines; (j) relative scarcity of
venture funds; (k) few commercial products; (l) big pharma’s reluctance to seriously invest in nanomedicine; (m)
confusion and delay at the PTO (with respect to proliferation of nanoparticle-related applications filed and patents
granted); (n) unpredictability at the FDA (with respect to a lack of clear regulatory or safety guidelines pertaining to
nanoparticles); and (o) media’s continuing focus on the negative aspects of nanoparticles, often without clear
scientific evidence.
45
See Raj Bawa, Patenting Inventions in Nanomedicine: A Catalyst for Commercialization? 5 S
MALL
T
IMES
16
(2005); Raj Bawa, Op. Ed. Will the Nanomedicine “Patent Land Grab” Thwart Commercialization? 1 N
ANOMED
.,
N
ANOTECH
.,
B
IO
.
&
M
ED
. 346 (2005).
46
See supra note 26; Drew L. Harris & Raj Bawa, The Carbon Nanotube Patent Landscape in Nanomedicine: an
Expert Opinion, 17(9) E
XPERT
O
PIN
.
T
HER
.
P
ATENTS
1165 (2007); see also Bawa supra notes 6 and 7.
47
See Glenn Hess, Patent Reform Stalls in Senate, 86(22) C
HEM
.
&
E
NG
’
G
N
EWS
40 (2008).
48
Current U.S. patent laws allow obtaining a patent on a new therapeutic formulation that has been created from
an old formulation, for instance via novel carriers, novel formulation techniques or through improved DDS. In other
words, “nanoformulations” of older therapeutics may be patentable. Innovative DDS could enable companies to
devise novel reformulations of off-patent or soon-to-be off-patent compounds. This strategy could delay or
discourage generic competition during the most profitable years of an innovator’s life cycle. This is especially true
if the reformulated therapeutic is superior to its off-patent or soon-to-be off-patent counterpart. In effect, this
approach stretches the product lifecycle of an existing, branded, patented therapeutic. This strategy, commonly
referred to as “product-line-extension” or “patent evergreening,” is broad in scope and includes any second-
Bawa
148 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
therapeutics should significantly impact the drug and biotechnology commercialization landscapes in the
near future.
V. CONCLUSIONS AND FUTURE PROSPECTS
Novel or reformulated nanoparticle-based therapeutics currently account for a tiny niche of the total
drug, biotech and device market. However, nanoparticle-based delivery holds enormous potential as an
effective approach for targeted drug or gene delivery. Nanoparticulate therapeutics of varying
compositions and properties have been formulated and characterized. The applications of this evolving
technology will be further expanded in the near future as we increase our knowledge of how the human
body transports, distributes and clears particles via the vascular and lymphatic systems (i.e.,
biodistribution of nanoparticles). This is likely to happen at a rapid pace once we develop imaging
modalities that provide a better understanding of the precise molecular targets and metabolic fates
following delivery of nanoparticles. Obviously, these advances will only come about if synthetic/
analytical technologies are coupled to in vitro/in vivo studies and undertaken prior to clinical trials.
Computer modeling and simulation techniques will also need to be developed to further our
understanding of drug nanoparticles. In addition, clinical trials will need to be conducted with well-
characterized nanoparticles. In this regard, an international central “Nanoparticle Databank” should be
created that characterizes nanoparticles and summarizes clinical trial data.
Clearly, nanoparticle-based “smart” therapeutics are here to stay and will generate both evolutionary
as well as revolutionary products in the future, which will impact the healthcare landscape. But, if this is
to happen, there are a few key biological requirements for such technologies to fulfill: (i) they must
exhibit “stealth” qualities to evade macrophage attack and the immune response; (ii) be nontoxic,
traceable and biodegradable following systemic administration through any route; (iii) display effective
pharmacokinetic properties; (iv) the polymer must protect the embedded therapeutics; and (v) they must
be selective in their targeting to specific tissue sites.
Finally, it is hoped that urgently needed reforms are undertaken at the PTO to address problems
ranging from poor patent quality and questionable examination practices, to inadequate search
capabilities, rising attrition, poor employee morale, and a skyrocketing patent application backlog. Only a
robust patent system will stimulate the development of commercially viable products. Similarly,
improvements are needed at the FDA. Additionally, the FDA must provide clear regulatory/safety
guidelines for therapeutic nanoparticles. It is also imperative that we all pay attention to the
environmental, health and societal implications of such nanoparticles.
Eventually, these undertakings will expand the burgeoning field of nanoparticle-based therapeutics.
Pharma and biotech will embrace nanoparticle-based therapeutics, especially if they offer novel properties
that meet medical needs and if the development costs and risks are low relative to commercializing new
therapeutics and delivery systems. It is hoped that, in the end, nanoparticle-based therapeutics will
become an integral part of mainstream medicine and a standard in the drug industry.
generation adaptation of an existing therapeutic that offers improved safety, efficacy or patient compliance. In fact,
reformulation strategies should focus on how to add value through added ease and convenience for the consumer. If
this approach is successful, the innovator of the new reformulation can maintain market share even after generics
appear in the marketplace. There are a number of DDS available that can be adapted to various therapeutic in an
effort to reformulate them to generate improvements with respect to delivery method, dosage form or dosage
strength. Improvements may also be created by conjugating, entrapping or modifying the active agent itself to
create a superior product (e.g., by creating pegylated versions or reformulating it with a new salt or ester). Another
often-employed approach is to develop and patent a novel polymorph of the innovator’s drug compound prior to
patent expiration.
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 149
APPENDIX
T
ABLE
1:
S
ELECTED
N
ANOPARTICLE
-
BASED
T
HERAPEUTICS
A
PPROVED BY THE
FDA
49
Product /
Brand
Name
Nanoparticle Drug
Component / Active
Ingredient(s)
Delivery
Route Company /
Alliance FDA Approved
Indication(s) FDA
Approval
Date
50
Doxil
Caelyx
(outside the
US)
pegylated doxorubicin
(Adriamycin)HCl
liposomes
IV OrthoBiotech
Schering-
Plough
metastatic ovarian
cancer and AIDS-
related Kaposi’s
sarcoma
November
1995
Abraxane paclitaxel (taxol) bound
albumin nanoparticles
(~130 nm)
IV Abraxis
BioScience
AstraZeneca
metastatic breast
cancer patients
who have failed
combination
therapy
January
2005
AmBisome amphotericin B liposomes
(~45-80 nm) IV Gilead Sciences fungal infections August
1997
Diprivan propofol liposomes IV Zeneca Pharma anesthetic October
1989
Renagel cross-linked
poly(allylamine) resin
(sevelamer hydrochloride)
oral tablets
(capsules
discontinued)
Genzyme control of serum
phosphorus in
patients with
chronic kidney
disease on dialysis
October
1998
Triglide nanocrystalline fenofibrate oral tablets SkyePharma
First Horizon lipid disorders;
markedly reduces
elevated plasma
concentrations of
triglycerides, LDL
and total
cholesterol and
raises abnormally
low levels of HDL
May 2005
Myocet liposome-encapsulated
doxorubicin-citrate
complex
IV Zeneus Pharma
Sopherion
Therapeutics
cardio-protective
formulation of
doxorubicin used
Approved
in Europe
and
49
The following abbreviations are used in the table: IV, intravenous; PEG-hGH, pegylated human growth hormone;
PEG-G-CSF, pegylated granulocyte colony-stimulating factor; nm, nanometer; PEG, polyethylene glycol; VEGF,
vascular endothelial growth factor; HDL, high-density lipoprotein; LDL, low-density lipoprotein; AIDS, acquired
immunodeficiency syndrome.
50
Note that therapeutic approval by FDA does not necessarily indicate that the therapeutic is available to consumers.
Data presented herein is current as of June 1, 2008. Myocet and Epaxal have not been approved by the FDA.
Marketed nanoparticulate products developed by Elan using NanoCrystal technology are shown separately in Table
3.
Bawa
150 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
Product /
Brand
Name
Nanoparticle Drug
Component / Active
Ingredient(s)
Delivery
Route Company /
Alliance FDA Approved
Indication(s) FDA
Approval
Date
50
in late stage
metastatic breast
cancer
Canada
DepoCyt sustained release
cytarabine liposomes IV SkyePharma
Enzon
lymphomatous
meningitis April
1999
DaunoXome encapsulated-daunorubicin
citrate liposomes IV Gilead Sciences advanced HIV-
related Kaposi's
sarcoma
April
1996
Estrasorb estradiol hemihydrate
micellar nanoparticles
(emulsion)
transdermal Novavax reduction of
vasomotor
symptoms, such
as hot flushes and
night sweats, in
menopausal
women
October
2003
Macugen pegylated anti-VEGF
aptamer intravitreal OSI
Pharmaceuticals
Pfizer
neovascular age-
related macular
degeneration
December
2004
Abelcet amphotericin B
phospholipid complex IV Enzon invasive fungal
infections in
patients who are
refractory to or
intolerant of
conventional
amphotericin B
therapy
November
1995
Adagen pegylated adenosine
deaminase IV Enzon enzyme
replacement
therapy for
patients with
severe combined
immunodeficiency
disease
March
1990
Pegasys peginterferon alfa-2a subcutaneous Nektar
Hoffmann-La
Roche
chronic hepatitis
C virus infection October
2002
Somavert pegvisomant (PEG-hGH) subcutaneous Nektar
Pfizer acromegaly March
2003
Neulasta PEG-G-CSF or
pegfilgrastim (covalent
conjugate of recombinant
methionyl human G-CSF
subcutaneous Amgen febrile
neutropenia January
2002
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 151
Product /
Brand
Name
Nanoparticle Drug
Component / Active
Ingredient(s)
Delivery
Route Company /
Alliance FDA Approved
Indication(s) FDA
Approval
Date
50
(Filgrastim) and
monomethoxypolyethylene
glycol)
Copaxone glatiramer acetate
(copolymer of L-glutamic
acid, L-alanine, L-tyrosine,
and L-lysine)
subcutaneous TEVA relapsing-
remitting multiple
sclerosis
December
1996
Amphotec colloidal suspension of
lipid-based amphotericin B
(~115 nm)
subcutaneous Sequus invasive
aspergillosis
patients who are
refractory to or
intolerant of
conventional
amphotericin B
November
1996
PEGIntron peginterferon alfa-2b subcutaneous Enzon
Schering-
Plough
chronic hepatitis
C virus infection
in patients with
compensated liver
disease
January
2001
Oncaspar pegasparginase subcutaneous Enzon leukemia February
1994
Epaxal hepatitis A vaccine
adjuvanted with
immunopotentiating
reconstituted influenza
virosomes (IRIV)
Intramuscular
(in the
deltoid
muscle)
Berna Biotech active
immunization
against hepatitis A
for adult and
children >12
months (age may
vary and depend
upon the country)
available
in Canada
and
elsewhere
Elestrin estradiol gel (0.06%)
incorporating calcium
phosphate nanoparticles
transdermal BioSanté treatment of
moderate to
severe hot flashes
in menopausal
women
December
2006
Bawa
152 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
T
ABLE
2:
S
ELECTED
N
ANOPARTICLE
-
BASED
T
HERAPEUTICS IN
C
LINICAL
T
RIALS
**
Product/
Brand Name
Nanoparticle Drug
Component / Active
Ingredient(s)
Delivery
Route Company Indication(s) Approval Status
VivaGel dendrimer gel topical
StarPharma
Holdings
Vaginal
microbicide for
the prevention of
HIV and genital
herpes
Phase II; Fast Track
CALAA-01
cyclodextrin-
containing siRNA
delivery
nanoparticles (~50
nm) based on
Calando's RONDEL
technology
intravenous Calando
Pharmaceutic
als various cancers Phase I
INGN-401 liposome FUS-1 intravenous Introgen
Therapeutics
metastatic, non-
small cell lung
cancer Phase I
Aurimmune
(CYT-6091)
colloidal gold
nanoparticles
coupled to TNF and
PEG-Thiol (~27 nm)
intravenous CytImmune
Sciences solid tumors Phase II
SGT-53
p
-53 liposomes intravenous Synergene
Therapeutics solid tumors Phase I
N
B-00X
nanoemulsion
droplets (~200 nm)
based on NanoStat
technology
topical
N
anoBio herpes labialis
caused by herpes
simplex I virus Phase II
AuroShell gold-coated silica
nanoparticles (~150
nm) intravenous
N
anospectra
Biosciences solid tumors Phase I
XMT-1001 Fleximer-
camptothecin
p
rodrug conjugate intravenous Mersana
Therapeutics
various cancers Phase I
**Data present herein is current as of June 1, 2008. List excludes compounds or formulations where human clinical
trials are being planned or are expected to be initiated.
The following abbreviations are used in the table: PEG, polyethylene glycol; nm, nanometer; siRNA, small
interfering ribonucleic acid; HIV, human immunodeficiency virus; TNF, tumor necrosis factor.
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 153
T
ABLE
3:
M
ARKETED
N
ANOPARTICULATE
P
RODUCTS
D
EVELOPED BY
E
LAN
U
SING
N
ANO
C
RYSTAL
T
ECHNOLOGY
Avinza
Once-daily, novel dual-release
morphine sulphate formulation;
marketed in the US
Megace ES
Concentrated oral suspension;
marketed in the US
TriCor
new formulation of fenofibrate,
which can be taken without regard to
food; launched in the US by Abbott
Emend
Oral capsule form of aprepitant, a
poorly water-soluble compound;
marketed in the US and other
territories
Naprelan
Once-daily, sustained-release
naproxen sodium; marketed in the US
Theodur
Twice-daily, sustained-release
theophylline for the Japanese market
Focalin XR
Once-daily extended release
dexmethylphenidate hydrochloride
Rapamume
Oral tablet of the poorly water-
soluble immunosuppressant,
sirolimus; marketed in the US
Verelan
Once-daily, sustained-release
verapamil; marketed worldwide
Herbesser
Once-daily, high-potency, sustained-
release diltiazem for Japanese and
other Asian markets
Ritalin LA
Once-daily, pulsatile release of
methylphenidate; marketed in the US
and other territories
Verelan PM
Modified-release, chronotherapeutic
verapamil; marketed in the US
Bawa
154 N
ANOTECHNOLOGY
L
AW
&
B
USINESS
• Volume 5 No. 2
F
IGURE
1:
N
ANOCRYSTAL PARTICLES ADSORBED WITH SURFACE STABILIZERS
Courtesy of Elan Corporation
F
IGURE
2:
RNA
I
/O
LIGONUCLEOTIDE
N
ANOPARTICLE
D
ELIVERY
(RONDEL)
T
ECHNOLOGY
Courtesy of Calando Pharmaceuticals, Inc.
Nanoparticle-based Therapeutics in Humans
N
ANOTECHNOLOGY
L
AW
&
B
USINESS
•
S
UMMER
2008 155
F
IGURE
3(
A
):
G
ROWTH OF A
D
ENDRIMER
N
ANOPARTICULATE
Courtesy of Starpharma Holdings Limited
F
IGURE
3(
B
):
S
TRUCTURE OF
D
ENDRITIC
D
RUG
-D
ELIVERY
V
EHICLES
Courtesy of Starpharma Holdings Limited