Dissolved-oxygen-stat fed-batch fermentation of 1,3-dihydroxyacetone from glycerol by Gluconobacter oxydans ZJB09112. Biotechnol. Bioprocess Eng. 15: 651-656

Biotechnology and Bioprocess Engineering (Impact Factor: 1.11). 08/2010; 15(4):651-656. DOI: 10.1007/s12257-009-3068-2


This study investigated the effects of DO concentration on DHA fermentation and of DO-stat fed-batch fermentation using a
pH control strategy, on 1,3-dihydroxyacetone (DHA) production. The results showed that DO-stat fed-batch fermentation with
pH-shift control was the optimal bioprocess for DHA production. DO-stat fed-batch fermentation was carried out at 30% air
saturation, and the culture pH was automatically maintained at pH 6.0 during the first 20 h and then shifted to pH 5.0 until
the end of the fermentation. An optimal DHA concentration of 175.9 ± 6.7 g/L, with a production yield to glycerol of 0.87
± 0.04 g/g, was obtained at 72 h of DO-stat fed-batch fermentation at 30°C in a 15 L fermenter.

Gluconobacter oxydans
-DO-stat fermentation-glycerol-fed-batch

1 Follower
20 Reads
  • [Show abstract] [Hide abstract]
    ABSTRACT: In the classical control of electrical drives fed by a pulse-width modulation (PWM) power converter, the inverter is considered as a simple transmission gain corresponding to the average modelling approach. This modelling is reasonable in many cases but shows its limits as the PWM period increases and becomes significant compared to the electrical and mechanical time constants of the machine. In this case, with classical controllers (PI, for example), a low frequency torque ripple appears
    Industrial Electronics, Control and Instrumentation, 1994. IECON '94., 20th International Conference on; 10/1994
  • [Show abstract] [Hide abstract]
    ABSTRACT: Klebsiella pneumoniae is a suitable biocatalyst for the production of 1,3-propanediol (1,3-PDO) and 3-hydroxypropionic acid (3-HP) from glycerol. However, its commercial applications have been impeded due to its poor growth characteristics and the excessive production of lipopolysaccharide (LPS). To overcome these limitations, a new K. pneumoniae J2B (KpJ2B) strain was isolated from municipal waste anaerobic digester samples. The shake flask cultivation of this new strain under aerobic conditions showed a specific growth rate of 0.92/h, which is 1.13 times higher than that achieved using the well studied K. pneumoniae DSMZ2026 (KpDSMZ). When the new strain was grown in a bioreactor under aerobic conditions using a fed-batch mode for 36 h, the biomass concentration (4.03 g/L CDW) and productivity (0.15 g/L/h) were almost 2.2 times higher than the corresponding values with KpDSMZ. Growth was accompanied by the production of 1,3-PDO (186 mM), lactic acid (235 mM), ethanol (170 mM), and acetic acid (92.2 mM) at significant levels, indicating the resistance of the strain to the inhibitory effects of these metabolites. A comparison of the SEM images and 2-keto-3-deoxyoctonate content (KpJ2B, 1.4 µg/g CDW; KpDSMZ, 1.9 µg/g CDW) confirmed the lower LPS content in the KpJ2B strain. Furthermore, this new isolate exhibited higher sensitivity towards a range of antibiotics and better sedimentation properties than the KpDSMZ strain. This suggests that KpJ2B is an attractive strain for industrial applications.
    Biotechnology and Bioprocess Engineering 01/2011; 16:1134-1143. · 1.11 Impact Factor
  • [Show abstract] [Hide abstract]
    ABSTRACT: 1,3-Dihydroxyacetone can be produced by biotransformation of glycerol with glycerol dehydrogenase from Gluconobacter oxydans cells. Firstly, improvement the activity of glycerol dehydrogenase was carried out by medium optimization. The optimal medium for cell cultivation was composed of 5.6g/l yeast extract, 4.7 g/l glycerol, 42.1g/l mannitol, 0.5 g/l K(2)HPO(4), 0.5 g/l KH(2)PO(4), 0.1g/l MgSO(4)·7H(2)O, and 2.0 g/l CaCO(3) with the initial pH of 4.9. Secondly, an internal loop airlift bioreactor was applied for DHA production from glycerol by resting cells of G. oxydans ZJB09113. Furthermore, the effects of pH, aeration rate and cell content on DHA production and glycerol feeding strategy were investigated. 156.3 ± 7.8 g/l of maximal DHA concentration with 89.8±2.4% of conversion rate of glycerol to DHA was achieved after 72h of biotransformation using 10g/l resting cells at 30°C, pH 5.0 and 1.5vvm of aeration rate.
    Bioresource Technology 07/2011; 102(14):7177-82. DOI:10.1016/j.biortech.2011.04.078 · 4.49 Impact Factor
Show more

Similar Publications